Wacker Neuson RD 27-100 User Manual

Maintenance RD 27
98 wc_tx000815gb.fm
5.42 Troubleshooting
Problem / Symptom Reason Remedy
Engine does not start Empty fuel tank Refill fuel tank.
Wrong type of fuel Drain tank, change fuel fil-
ter, and refill with the proper
fuel.
Old fuel Drain tank, change fuel fil-
ter, and refill with fresh fuel.
Fuel system not primed Prime the fuel system.
Fuel filter restricted or
plugged
Replace fuel filter.
Battery connections are
loose or corroded, or bat-
tery is dead.
Check battery connections
or replace battery as
needed.
Plugged air cleaner or filter
elements
Clean air cleaner or replace
filter elements.
Defective starter motor Repair or replace.
Inoperative fuel solenoids
on engine
Repair or replace.
Inoperative starter relay Repair or replace.
Loose or broken electrical
connections
Check connections and
tighten or repair as needed.
Engine stops by itself Empty fuel tank Refill fuel tank.
Clogged fuel filter Clean or replace.
Loose or broken fuel lines Check connections and
tighten or repair as needed.
No vibration Defective switch or poor
connection
Check components and
tighten or repair as needed.
Damaged or disconnected
solenoid on vibration valve
Reconnect or repair sole-
noid.
Damaged exciter assembly Repair the assembly.
Damaged or broken exciter
motor coupling
Repair or replace.
Damaged exciter motor Repair or replace.
Damaged exciter pump Repair or replace.
Damaged exciter bearings Repair or replace.

Wacker Neuson RD 27-100 Specifications

General

Brand	Wacker Neuson
Model	RD 27-100
Category	Power Roller
Language	English