10 SERVICE SCHEDULE
42
10.1 Additional information
Any further work that results from the required work or from the recommended work must be ordered sepa-
rately and can be invoiced separately.
10.2 Required work
Every 45 operating hours
Every 30 operating hours/after every race
Every 15 operating hours
Once after 1 operating hour
Read out the fault memory using the Husqvarna Motorcycles diagnostics tool. ○ ● ● ●
Check that the electrical system is functioning properly. ○ ● ● ●
Check and charge the battery. ● ● ●
Check the front brake linings. ( p. 91) ● ● ●
Check the rear brake linings. ( p. 97) ● ● ●
Check the brake discs. ( p. 89) ● ● ●
Check the brake lines for damage and leakage. ● ● ●
Check the rear brake fluid level. ( p. 95) ● ● ●
Check the free travel of the foot brake lever. ( p. 94) ● ● ●
Check the frame. ( p. 84) ● ● ●
Check the swingarm. ( p. 84) ● ● ●
Check the swingarm bearing for play. ●
Check the heim joint for play. ● ● ●
Check the shock absorber linkage. ● ● ●
Check the tire condition. ( p. 105) ○ ● ● ●
Check the tire air pressure. ( p. 105) ○ ● ● ●
Check the wheel bearing for play. ● ● ●
Check the wheel hubs. ● ● ●
Check the rim run-out. ○ ● ● ●
Check the spoke tension. ( p. 106) ○ ● ● ●
Check the chain, rear sprocket, engine sprocket and chain guide. ( p. 81) ● ● ●
Check the chain tension. ( p. 80) ○ ● ● ●
Grease all moving parts (e.g. side stand, hand lever, chain, ...) and check for smooth oper-
ation.
● ● ●
Check/correct the fluid level of the hydraulic clutch. ( p. 86) ● ● ●
Check the front brake fluid level. ( p. 90) ● ● ●
Check the free travel of the hand brake lever. ● ● ●
Check the play of the steering head bearing. ( p. 61) ○ ● ● ●
Check the valve clearance. ○ ●
Check the clutch. ●
Change the engine oil and oil filter and clean the oil screens. ( p. 129) ○ ● ● ●
Check all hoses (e.g. fuel, cooling, bleeder, drainage, etc.) and sleeves for cracking, leaks,
and incorrect routing.
○ ● ● ●
Check the antifreeze and coolant level. ( p. 118) ○ ● ● ●
Check the cables for damage and routing without sharp bends. ● ● ●
To Next Page
Loading...
Need help?
General
