STORAGE 68
17.1Storage
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
– Avoid contact between fuel and skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse immedi-
ately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed, con-
tact a doctor immediately. Change clothing that has come into contact with fuel. Store fuel in a suitable canister according
to regulations and keep it out of the reach of children.
Info
If you want to garage the motorcycle for a longer period, take the following actions.
Before storing the motorcycle, check all parts for function and wear. If service, repairs or replacements are necessary, you
should do this during the storage period (less workshop overload). In this way, you can avoid long workshop waiting times at the
start of the new season.
– Clean the motorcycle. ( p. 67)
–
Change the gear oil. x ( p. 64)
– Check the antifreeze and coolant level. ( p. 59)
– Drain the fuel from the tank into a suitable container.
–
Empty the carburetor float chamber. x ( p. 63)
– Check the tire air pressure. ( p. 57)
– Store the vehicle in a dry location that is not subject to large fluctuations in temperature.
Info
KTM recommends raising the motorcycle.
– Raise the motorcycle with a lift stand. ( p. 26)
– Cover the vehicle with a tarp or similar cover that is permeable to air.
Info
Do not use non-porous materials since they prevent humidity from escaping, thus causing corrosion.
Avoid running the engine for a short time only. Since the engine cannot warm up properly, the water vapor produced during
combustion condenses and causes valves and exhaust system to rust.
17.2Preparing for use after storage
– Remove the motorcycle from the lift stand. ( p. 26)
– Fill up with fuel. ( p. 17)
– Perform checks and maintenance measures when preparing the motorcycle for use. ( p. 15)
– Take a test ride.
To Next Page
Loading...
Need help?
General
