TP-7070 7/1876 Section 3 Scheduled Maintenance
3.3 APM802 Controller
Maintenance
The APM802 controller uses two BR2032 internal
batteries in the controller base module and HMI to
preserve the time, date, and generator set events. If
battery power is low, an alarm, M3.212 APM INTERNAL
BATTERY WARNING, appears on the controller. Have
an authorized Kohler service representative service the
controller.
3.4 Engine Maintenance
Regular engine maintenance is essential. Perform
engine maintenance at the intervals specified in the
engine operation and maintenance manuals. Contact
an authorized service distributor/dealer to obtain engine
literature. Refer to the engine operation manual for the
following:
D Engine operation
D Engine maintenance schedules (can vary depending
on engine application)
D Engine maintenance procedures
D Fuel, lubricant, and coolant specifications
3.5 Diesel Fuel Systems
Explosive fuel vapors.
Can cause severe injury or death.
Use extreme care when handling,
storing, and using fuels.
WARNING
The fuel system. Explosive fuel vapors can cause severe
injury or death. Vaporized fuels are highly explosive. Use
extreme care when handling and storing fuels. Store fuels in a
well-ventilated area away from spark-producing equipment
and out of the reach of children. Never add fuel to the tank
while the engine is running because spilled fuel may ignite on
contact with hot parts or from sparks. Do not smoke or permit
flames or sparks to occur near sources of spilled fuel or fuel
vapors. Keep the fuel lines and connections tight and in good
condition. Do not replace flexible fuel lines with rigid lines. Use
flexible sections to avoid fuel line breakage caused by
vibration. Do not operate the generator set in the presence of
fuel leaks, fuel accumulation, or sparks. Repair fuel systems
before resuming generator set operation.
Draining the fuel system. Explosive fuel vapors can
cause severe injury or death. Spilled fuel can cause an
explosion. Use a container to catch fuel when draining the fuel
system. Wipe up spilled fuel after draining the system.
To Next Page
Loading...
Need help?
General