Name: KTM 250 SX-F EU 2010
Brand: KTM
Rating: 5 (1 reviews)

To Next Page

To Previous Page

CONTROLS 14

5.11Overview of indicator lamps (EXC-F, EXC‑F SIX DAYS)

500147-01

Possible states

High beam indicator lamp lights up blue – High beam is switched on.

Turn signal indicator lamp flashes green – Turn signal light is switched

on.

Table of Contents4
Means of Representation7
Important Information8
View of Vehicle10
- View of the Vehicle from the Left Front (Example)10
- View of the Vehicle from the Right Rear (Example)11
Location of Serial Numbers12
- Chassis Number12
- Type Label12
- Key Number (EXC-F, EXC-F SIX DAYS)12
- Engine Number12
- Fork Part Number12
- Shock Absorber Part Number13
Controls14
- Clutch Lever14
- Hand Brake Lever14
- Short Circuit Button (XCF-W, SX-F)14
- Short Circuit Button (EXC-F, EXC-F SIX DAYS)14
- Emergency off Switch (EXC-F AUS)14
- Electric Starter Button (EXC-F EU, EXC-F SIX DAYS, XCF-W)15
- Electric Starter Button (EXC-F AUS)15
- Light Switch (EXC-F, EXC-F SIX DAYS)15
- Horn Button (EXC-F, EXC-F SIX DAYS)15
- Turn Signal Switch (EXC-F, EXC-F SIX DAYS)15
- Overview of Indicator Lamps (EXC-F, EXC-F SIX DAYS)16
Controls (Exc-F, Exc-F Six Days, Xcf-W)17
- Speedometer17
- Speedometer Activation and Test17
- Tripmaster Switch17
- Setting Kilometers or Miles17
- Setting the Clock18
- Adjusting the Speedometer Functions18
- Querying the Lap Time19
- SPEED Display Mode (Speed)19
- Display Mode SPEED/H (Service Hours)19
- Display Mode SPEED/CLK (Clock)20
- Display Mode SPEED/LAP (Lap Time)20
- Display Mode SPEED/ODO (Odometer)20
- Display Mode SPEED/TR1 (Trip Master 1)20
- Display Mode SPEED/TR2 (Trip Master 2)21
- Disply Mode SPEED/A1 (Average Speed 1)21
- Display Mode SPEED/A2 (Average Speed 2)21
- Display Mode SPEED/S1 (Stop Watch 1)22
- Display Mode SPEED/S2 (Stop Watch 2)22
Controls24
- Fuel Tap (EXC-F, EXC-F SIX DAYS, XCF-W)24
- Fuel Tap (SX-F)24
- Opening Filler Cap24
- Closing Filler Cap25
- Choke (EXC-F EU, EXC-F SIX DAYS)25
- Choke (XCF-W, SX-F, EXC-F AUS)25
- Shift Lever25
- Foot Brake Lever26
- Kick Starter26
- Side Stand (EXC-F, EXC-F SIX DAYS, XCF-W)26
- Plug-In Stand (SX-F)26
- Steering Lock (EXC-F, EXC-F SIX DAYS)27
- Locking the Steering (EXC-F, EXC-F SIX DAYS)27
- Unlocking the Steering (EXC-F, EXC-F SIX DAYS)27
General Tips and Hints on Putting into Operation28
- Advice on First Use28
- Running-In the Engine29
- Preparing Vehicle for Arduous Riding Conditions29
- Preparing for Riding on Dry Sand29
- Preparing for Riding on Wet Sand30
- Preparing for Riding on Wet and Muddy Surfaces31
- Preparing for Rides at High Temperature and Slow Speed32
- Preparing for Rides at Low Temperatures or in Snow32
Riding Instructions33
- Checks before Putting into Operation33
- Starting33
- Starting up34
- Shifting, Riding34
- Braking34
- Stopping, Parking35
- Refueling35
Service Schedule (Exc-F, Exc-F Six Days, Xcf-W)37
- Important Maintenance Work to be Carried out by an Authorized KTM Workshop37
- Important Maintenance Work to be Carried out by an Authorized KTM Workshop (as Additional Order)38
Service Schedule (Sx-F)39
- Important Maintenance Work to be Carried out by an Authorized KTM Workshop39
- Important Maintenance Work to be Carried out by an Authorized KTM Workshop (as Additional Order)40
Service Schedule for Rider41
- Important Checks and Maintenance Work to be Carried out by the Rider41
Maintenance Work on Chassis and Engine42
- Jacking up the Motorcycle42
- Removing the Motorcycle from the Work Stand42
- Checking the Basic Suspension Setting with the Rider's Weight42
- Compression Damping of Shock Absorber42
- Adjusting High-Speed Compression Damping of the Shock Absorber42
- Adjusting the Low-Speed Compression Damping of the Shock Absorber43
- Adjusting the Rebound Damping of the Shock Absorber44
- Measuring Rear Wheel Sag Unloaded44
- Checking the Static Sag of the Shock Absorber45
- Checking the Riding Sag of the Shock Absorber45
- Adjusting the Spring Preload of the Shock Absorber45
- Adjusting the Riding Sag46
- Removing the Shock Absorber47
- Installing the Shock Absorber47
- Checking Basic Setting of Fork47
- Adjusting the Compression Damping of the Fork47
- Adjusting the Rebound Damping of the Fork48
- Adjusting the Spring Preload of the Fork (EXC-F, EXC-F SIX DAYS, XCF-W)49
- Bleeding Fork Legs50
- Cleaning the Dust Boots of the Fork Legs50
- Loosening the Fork Protector50
- Positioning the Fork Protection50
- Checking Steering Head Bearing Play51
- Adjusting Play of Steering Head Bearing (EXC-F EU, EXC-F AUS, XCF-W ZA)51
- Adjusting the Play of the Steering Head Bearing (SX-F, 250 EXC-F SIX DAYS EU)52
- Removing the Fork Legs52
- Installing the Fork Legs53
- Removing the Fork Protector54
Installing the Fork Protector54
Removing the Front Fender54
Installing the Front Fender55
Removing Headlight Mask with Headlight (EXC-F, EXC-F SIX DAYS, XCF-W)55
Refitting the Headlight Mask with the Headlight (EXC-F, EXC-F SIX DAYS, XCF-W)55
Removing the Start Number Plate (SX-F)56
Installing the Start Number Plate (SX-F)56
Handlebar Position56
Adjusting Handlebar Position56
Checking Throttle Cable Route57
Checking the Play in the Throttle Cable57
Adjusting the Play in the Throttle Cable58
Checking for Chain Dirt Accumulation58
Cleaning the Chain58
Checking the Chain Tension59
Checking Chain Tension When Fitting Rear Wheel59
Checking the Rear Sprocket/Engine Sprocket for Wear59
Checking Chain Wear60
Adjusting Chain Tension60
Adjusting Chain Tension - after Checking61
Adjusting Chain Tension - Fitting Rear Wheel62
Adjusting the Chain Guide (EXC-F, EXC-F SIX DAYS, XCF-W)62
Adjusting the Chain Guide (SX-F)63
Checking Brake Discs63
Checking Free Travel of Hand Brake Lever63
Adjusting Basic Position of Hand Brake Lever (XCF-W, SX-F)64
Adjusting Free Travel of Hand Brake Lever (EXC-F, EXC-F SIX DAYS)64
Checking the Brake Fluid Level of the Front Brake64
Topping up the Front Brake Fluid65
Checking the Front Brake Linings66
Changing the Front Brake Linings66
Checking Free Travel of Foot Brake Lever68
Adjusting Basic Position of Footbrake Lever68
Checking Rear Brake Fluid Level68
Adding Brake Fluid to the Rear Brake Circuit69
Checking Rear Brake Linings69
Changing the Rear Brake Linings70
Removing Front Wheel71
Installing the Front Wheel72
Removing the Rear Wheel73
Installing the Rear Wheel73
Tire Condition Checking74
Checking Tire Air Pressure75
Checking Spoke Tension75
Removing the Battery (EXC-F, EXC-F SIX DAYS, XCF-W)76
Installing the Battery (EXC-F, EXC-F SIX DAYS, XCF-W)76
Recharging the Battery (EXC-F, EXC-F SIX DAYS, XCF-W)76
Removing a Fuse (EXC-F, EXC-F SIX DAYS, XCF-W)77
Replacing the Fuse (EXC-F, EXC-F SIX DAYS, XCF-W)77
Adjusting the Beam Width of the Headlight (EXC-F, EXC-F SIX DAYS, XCF-W)78
Checking the Headlight Adjustment (EXC-F, EXC-F SIX DAYS, XCF-W)78
Removing the Seat78
- Mounting the Seat79
- Dismounting the Fuel Tank79
- Installing the Fuel Tank80
- Cooling System80
- Checking the Anti-Freeze and Coolant Level81
- Checking the Coolant Level81
- Draining the Coolant82
- Refilling Coolant82
- Glass Fiber Yarn Filling of Main Silencer83
- Removing Main Silencer83
- Installing the Main Silencer83
- Removing the Air Filter Box Lid83
- Installing the Air Filter Box Lid83
- Removing the Air Filter84
- Installing the Air Filter84
- Cleaning Air Filter84
- Adjusting Basic Position of Clutch Lever85
- Checking the Fluid Level of Hydraulic Clutch85
- Changing the Hydraulic Clutch Fluid85
- Checking the Basic Position of the Shift Lever86
- Adjusting the Basic Position of the Shift Lever86
- Carburetor - Idle87
- Carburetor - Adjusting Idle87
- Emptying the Carburetor Float Chamber88
- Checking the Engine Oil Level89
- Changing the Engine Oil and Oil Filter, Cleaning the Oil Screen89
- Draining the Engine Oil89
- Cleaning the Oil Screens90
- Removing the Oil Filter91
- Installing the Oil Filter91
- Filling up with Engine Oil92
- Adding Engine Oil92
Troubleshooting93
Cleaning95
- Cleaning the Motorcycle95
Storage96
- Putting into Operation after Storage96
Technical Data - Engine97
- Capacity - Engine Oil98
- Capacity - Coolant98
Technical Data - Engine Tightening Torques99
Technical Data - Carburetor101
- Exc-F, Exc-F Six Days101
- Xcf-W101
- Sx-F101
Technical Data - Chassis102
- Lighting Equipment102
- Tires103
- Capacity - Fuel103
Technical Data - Fork104
- Exc-F, Exc-F Six Days, Xcf-W104
- Sx-F Eu104
- Sx-F Usa105
Technical Data - Shock Absorber106
- Exc-F, Exc-F Six Days, Xcf-W106
- Sx-F106
Technical Data - Tightening Torques for Chassis107
Wiring Diagram108
- Wiring Diagram (EXC-F EU, EXC-F SIX DAYS)108
- Wiring Diagram (EXC-F AUS)112
- Wiring Diagram (XCF-W)114
- Wiring Diagram (SX-F)116
Substances118
Auxiliary Substances119
Standards121
Index122

KTM 250 SX-F EU 2010 User Manual

Table of Contents

Questions and Answers:

KTM 250 SX-F EU 2010 Specifications

Related product manuals

Brand	KTM
Model	250 SX-F EU 2010
Category	Motorcycle
Language	English