Suzuki drz 400 2000 User Manual

GENERAL INFORMATION 1-3
A CAUTION
• If parts replacement is necessary, replace the parts with SUZUKI Genuine Parts or their equiva-
lent.
•
When removing parts that are to be reused, keep them arranged in an orderly manner so that
they may be reinstalled in the proper order.
• Be sure to use special tools when instructed .
• Make sure that all parts used in reassembly are clean. Lubricate them when specified .
.. Use the specified lubricants , bonds , or sealants.
•
When removing the battery, disconnect the e battery lead wire first , then the EEl battery lead
wire.
• When
reconnecting the battery, connect the EEl battery lead wire first , then the e battery lead
wire. Finally, cover the EEl battery terminal with the terminal cover .
• When performing service to electrical parts , disconnect the e battery lead wire , unless the
service procedure requires the battery power .
• When tightening cylinder head and crankcase nuts and bolts , tighten the larger sizes first.
Always tighten the nuts and bolts from the inside working out , diagonally and to the specified
torque .
• Whenever you remove oil seals, gaskets , packing , O-rings , self-locking nuts , locking wash -
ers. cotter pins. circlips. and other specified parts, be sure to replace them with new ones .
Also , before installing these new parts , be sure to remove any left over material from the
mating surfaces.
.. Never reuse a circlip. When installing a new circlip , take care not to expand the end gap larger
than required to slip the circlip over the shaft. After installing a circlip , always ensure it is
completely seated in its groove and securely fitted.
.. Use a torque wrench to tighten fasteners to the specified torque. Wipe off grease and oil if a
thread is smeared with them.
• After reassembling, check parts for tightness and proper operation.
• To protect the environment , do not unlawfUlly dispose of used motor oil , engine coolant , all
other fluids , batteries, and tires .
• To protect the earth's natural resources, properly dispose of used motorcycles and parts.
http://www.motorcycle.in.th

Suzuki drz 400 2000 Specifications

General

Brand	Suzuki
Model	drz 400 2000
Category	Motorcycle
Language	English