Suzuki drz 400 2003 Service Manual

ENGINE OIL AND OIL FILTER
ENGINE OIL
Replace initially at 1 000 km (600 miles , 1 month) and
every 6 000 km (4 000 miles , 6 months) thereafter .
ENGINE OIL FILTER
Replace initially at 1 000 km (600 miles , 1 month) and
every 18 000 km (11 000 miles , 18 months) thereafter.
The oil should be changed while the engine is warm. Oil filter
replacement at the above in tervals, should be done together wi th
the engine oil change.
ENGINE OIL REPLACEMENT
• Pl ace an oi l pan below the engine, and then drain the oi l by
removi ng the engine oi l drain plugs ( CD, @) and engine oil
fil ler cap @.
• Tighten the engine oil drain plugs ( CD , @) to the specified
torque , and then pour the nPow nil thrnlloh thp ni l fillAr holR
When performing an oi l change (without oil fi lter replacement),
the en gi ne wi ll hold about 1.7 L (1.8 US qt, 1.5 Imp qt) of oil.
U se an engine oil that meets A rl se r vice classi f ica t ions SF or
SG and that has a viscosity rating of SAE 10W-40.
~ Engine oil drain plug
(on the crankcase) CD :
(on the frame) @:
[A CAUTIO ]]
21 N·m (2.1 kgf-m , 15.0 Ib-ft)
18 N·m (1.8 kgf-m , 13.0 Ib-ft)
When installing the engine oil drain plug @ with gas-
ket, face me taper of gasket to Clraln plug as shown.
• Make sure that the engine is cooled.
• Plact: the .. notorcycle on level ground and hold it vertically.
• Install the oil filler cap @.
• Start the engine and allow it to run for three minutes at idling
speed.
• Turn off the engine and wait about three minutes, and then
check the oil level on the dipstick @. The oi l level should be
be tween the "L' (low) and "F" (full) level lines. If the oil level is
lower than the "L' level line, add oil to the "F" level line.
NOTC:
Engine oi l expa nd s and oi l level increase when the engine oil is
hot.
PERIODIC MAINTENANCE 2-11
http://www.motorcycle.in.th

Suzuki drz 400 2003 Specifications

General

Brand	Suzuki
Model	drz 400 2003
Category	Motorcycle
Language	English