Manitowoc Grove RT9130E-2 Service And Maintenance Manual

INTRODUCTION RT9130E-2 SERVICE MANUAL
1-2 Published 11-22-2016, Control # 345-12
When operating the crane, these reference
locations are to be considered as those viewed
from the operator’s seat with the superstructure
facing forward over the front of the carrier frame.
NOTE: The Transportation and Lifting Data Decal is shown
in (Figure 1-1). Basic nomenclature is shown in
(Figure 1-2).
LIST OF SPECIFICATIONS
General
Model . . . . . . . . . . . . . . . . . . . . . . RT9000E Series
Rated Capacity . . . . . . . . . . See Load Chart in cab
Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 x 4 x 4
Gross Weight . . . . . . . . . . . . . . . . See Axle Weight
. . . . . . . . . . . . . . . . . . . . . . . . . . Distribution Table
Dimensions
NOTE: Dimensions listed are for a crane with all
components fully retracted in the travel mode with
33.25 x 29 tires.
Wheelbase . . . . . . . . . . . . . . . .194.5 in (4940 mm)
Overall Crane Length . . . . . . . . 54 ft 1 in (16.48 m)
Overall Crane Width . . . . . . . . . . 12 ft 5 in (3.80 m)
Overall Crane Height 13 ft 8.25 in (4.172 mm) (Std)
. . . . . . . . . . . . . . . . . . . .13 ft 5 in (4089 mm) (Opt)
Tail-Swing . . . . . . . . . . . . . . . .14 ft 2.5 in (4.331 m)
Outrigger Spread
Retracted . . . . . . . . . . . . . . . 11 ft 8 in (3.56 m)
Mid Extend . . . . . . . . . . . . . . 19 ft 9 in (6.02 m)
Fully Extended . . . . . . . . . . 27 ft 10 in (8.49 m)
Capacities
Fuel Tank . . . . . . . . . . . . . . . . . . . . .100 gal (378 l)
Coolant System. . . . . . . . . . . . . . . . . . . See Engine
Manual
Engine Lubrication System . . . . . . . . . . See Engine
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Manual
Hydraulic Tank (Reservoir Capacity)
Total . . . . . . . . . . . . . . . . . . . . .360 gal (1363 l)
at Full Level . . . . . . . . . . . . . 324.1 gal (1226 l)
at Low Level . . . . . . . . . . . . 310.6 gal (1176 l)
Expansion Space . . . . . . . . . . . . 13.5 gal (51 l)
Hoists . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 qt (21 l)
Swing Gearbox . . . . . . . . . . . . . . . . . . .5-1/4 qt (5 l)
Axle Planetary Hubs . . . . . . . . . . . . . . . . 12 qt (11 l)
Axle Differentials. . . . . . . . . . . . . . . .29 qt (27-1/2 l)
Transmission (Includes Torque Converter)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 qt (32 l)
Torque Converter
Stall Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.29:1
Charge Pump Capacity. . . . . . 31 gpm (117.3 l/min)
@ 2000 rpm
Transmission
Gear Ratios:
Forward
1st . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7.87
2nd. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.94
3rd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.98
4th . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.25
5th . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.95
6th . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.73
Reverse
1st . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7.87
2nd. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.98
3rd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.95
Engine
Cummins QSL or (QSC)
HP Rating . . . . . . . . . . . .320 (300) hp @ 2200 rpm
Peak Torque . . . . . . .1020 (1000) lb-ft @ 1500 rpm
Lube Amount . . . . . . . . . . .24 (20)qt [22.7 l(18.9 l)]
Coolant System . . . . . . . . . . . . . . . . . 36 qt (34.1 l)
Axles
Total Ratio (w/differential lock) . . . . . . . . . . 33.43:1
Total Ration (standard) . . . . . . . . . . . . . . . . 31.94:1
Carrier Ratio (w/differential lock) . . . . . . . . 6.429:1
Carrier Ratio (standard) . . . . . . . . . . . . . . . 6.143:1
Planetary Ratio . . . . . . . . . . . . . . . . . . . . . . . 5.20:1

Manitowoc Grove RT9130E-2 Specifications

General

Brand	Manitowoc
Model	Grove RT9130E-2
Category	Construction Equipment
Language	English