Nilfisk-Advance Advolution 2710 Service Manual

56 - FORM NO. 56043107 - Advolution™ 2710 / UHR 70-1700
ELECTRICAL SYSTEM
WIRING DIAGRAM / SCHEMATIC
Item Description
A1 Speed Controller
CB1 Circuit Breaker, 5 Amp (Control)
CB2 Circuit Breaker, 40 Amp (Traction Drive)
F1 Fuse, 150 Amp
H1 Horn / Back-Up Alarm
K1 Contactor 36V (Pad Motor)
LP5 Headlight (Optional)
LP6 Beacon, Warning (Optional)
M1 Motor / Drive Wheel
M2 Motor (Pad Drive)
M3 Actuator, Motor
M4 Dust Control Vac Motor (Optional)
R1 Potentiometer, 5K
S1 Switch, Key (Main)
S2 Switch, Seat
S3 Sensor, Proximity
S10 Disconnect, Emergency
BLK
RED
RED/GRN YEL/BLK BLK
GRN/WHT
BRN/BLK
GRA
VIO/BRN
RED
GRN
RED/WHT
ORN
RED/WHT
VIO/BRN
RED RED
WHT/RED
GRNVIO
VIO
VIO
VIO
WHT/ORN
WHT/ORN
WHT/BRN
WHT/BRN
GRN/BLK
GRN/BLK
ORN/BLK
ORN/BLK
GRA/BLK
VIO/BLK
GRA/WHT
BRN/WHT
ORN/BLU
BLK/WHT
BLU/WHT
RED BLK
BLK/YEL
RED
BLK
BLK
RED/WHT
BLKWHT
VIO
RED BLK
BLK
BLK/GRA
BLU
PINK
ORN/WHT
BLU/BLK
BRN
YEL/WHT
YEL/WHT
GRNYEL
WHT/ORN
J2-4 (ACC (-))
J3-1 (B+)
J3-9 (SEAT SW)
J3-2 (KEY SW)
J3-10 (F/R)
(MODE) J2-2
(STATUS) J3-4
I/O PANEL
(B-) J2-10
(B-) J3-8
(SENSE) J3-3
(ACT 1) J2-12
(ACT 2) J2-6
(HORN +) J2-7
(HORN -) J2-1
J2-11 (PAD CONT +)
J2-5 (PAD CONT -)
J3-7 (INTERLOCK B-)
J3-5 (INTERLOCK)
CONTROL BOX
ON-BOARD
BATTERY CHARGER
(OPTIONAL)
56015612 REV. E
(B-) J2-9
J4-6 (PAD SW)
J4-1 (SDA)
J4-2 (SCL)
J4-3 (+5 V)
J4-5 (B-)
J4-4 (HORN SW)
(PAD SW) J1-6
(B-) J1-5
(+5 V) J1-3
(SCL) J1-2
(SDA) J1-1
(HORN SW) J1-4
(REV) J3-6
M
M2
MOTOR, PAD
M
M2
MOTOR, PAD
-+
K1K1
12
PLUG AC MALEPLUG AC MALE
S5
SW SPST
S5
SW SPST
12
CB2
CIRCUIT BREAKER, 40 AMP
CB2
CIRCUIT BREAKER, 40 AMP
12
H1
HORN/BACK-UP ALARM
H1
HORN/BACK-UP ALARM
+-
M
M4
MOTOR, DUST CONTROL VAC
(OPTIONAL)
M
M4
MOTOR, DUST CONTROL VAC
(OPTIONAL)
12
R1
POT. 5K OHM
R1
POT. 5K OHM
1
2
3
---
BT1
BATTERY, 36 VDC
---
BT1
BATTERY, 36 VDC
J7J7
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 17 18
S9
SW SPST
S9
SW SPST
12
S2
SWITCH, SEAT
S2
SWITCH, SEAT
21
S3
SWITCH, DECK INTERLOCK
S3
SWITCH, DECK INTERLOCK
12
LP6
LAMP, FLASHING
(OPTIONAL)
LP6
LAMP, FLASHING
(OPTIONAL)
12
Y1
BRAKE
Y1
BRAKE
12
LP5
LAMP, HEAD
(OPTIONAL)
LP5
LAMP, HEAD
(OPTIONAL)
12
K1
COIL, RELAY
K1
COIL, RELAY
M
M1
MOTOR, TRACTION
M
M1
MOTOR, TRACTION
-+
F1
FUSE, 150 A.
F1
FUSE, 150 A.
12
A1
CURTIS 1228 SPEED CONTROLLER
A1
CURTIS 1228 SPEED CONTROLLER
B+
B-
M1 (a) M2 (a) M1 (b) M2 (b)
S1
SWITCH, KEY
S1
SWITCH, KEY
12
M
M3
ACTUATOR
M
M3
ACTUATOR
-+
S10
EMERGENCY STOP
S10
EMERGENCY STOP
CB1
CIRCUIT BREAKER, 5 AMP
CB1
CIRCUIT BREAKER, 5 AMP
12

Nilfisk-Advance Advolution 2710 Specifications

General

Brand	Nilfisk-Advance
Model	Advolution 2710
Category	Floor Machine
Language	English