4
HCD-FLX5D/FLX7D
TABLE OF CONTENTS
1. SERVICING NOTES ................................................ 5
2. GENERAL
Location of Controls ....................................................... 9
Setting the Clock ............................................................. 10
3. DISASSEMBLY
3-1. Disassembly Flow ........................................................... 11
3-2. Cover (Top), Cover (Back) ............................................. 12
3-3. Case ................................................................................. 12
3-4. Front Panel Assy ............................................................. 13
3-5. Mechanical (Cassette) Deck ........................................... 14
3-6. GC Board......................................................................... 14
3-7. DVD Mechanism Block .................................................. 15
3-8. DSP Board....................................................................... 15
3-9. DVD Mechanism Deck (CDM53N-DVBU14) .............. 16
3-10. Fitting Base (Guide) Assy, Bracket (Chassis),
Magnet Assy .................................................................... 16
3-11. Base Unit (DVBU14) ...................................................... 17
3-12. Tray (Sub)........................................................................ 17
3-13. Chassis (Mold B) Section, Stocker Section,
Slider (Selection) ............................................................ 18
3-14. VIDEO Board.................................................................. 18
3-15. SUB TRANS Board ........................................................ 19
3-16. Back Panel Section.......................................................... 19
3-17. TRANS Board ................................................................. 20
3-18. SP RELAY Board............................................................ 20
4. ASSEMBLY
4-1. Assembly Flow................................................................ 21
4-2. Gears Installation ............................................................ 21
4-3. Slider (Selection) Installation ......................................... 22
4-4. Stocker Section Installation ............................................ 22
4-5. Chassis (Mold B) Section Installation............................ 23
5. TEST MODE.............................................................. 24
6. ELECTRICAL ADJUSTMENTS......................... 33
7. DIAGRAMS
7-1. Block Diagram − RF SERVO Section −........................ 34
7-2. Block Diagram − TUNER/TAPE DECK Section − ...... 35
7-3. Block Diagram − AUDIO DSP Section (1/2) −
(FLX7D only).................................................................. 36
7-4. Block Diagram − AUDIO DSP Section (2/2) − ............ 37
7-5. Block Diagram − POWER AMP Section − ................... 38
7-6. Block Diagram − VIDEO Section − .............................. 39
7-7. Block Diagram
− DISPLAY/POWER SUPPLY Section − ...................... 40
7-8. Note for Printed Wiring Boards and
Schematic Diagrams ....................................................... 41
7-9. Printed Wiring Board – RF Board − .............................. 42
7-10. Schematic Diagram – RF Board −................................. 43
7-11. Printed Wiring Board
− MB Board (Component Side) − .................................. 44
7-12. Printed Wiring Board
− MB Board (Conductor Side) − .................................... 45
7-13. Schematic Diagram − MB Board (1/7) − ...................... 46
7-14. Schematic Diagram − MB Board (2/7) − ...................... 47
7-15. Schematic Diagram − MB Board (3/7) − ...................... 48
7-16. Schematic Diagram − MB Board (4/7) − ...................... 49
7-17. Schematic Diagram − MB Board (5/7) − ...................... 50
7-18. Schematic Diagram − MB Board (6/7) − ...................... 51
7-19. Schematic Diagram − MB Board (7/7) − ...................... 52
7-20. Schematic Diagram − DSP Board (1/3) − ..................... 53
7-21. Schematic Diagram − DSP Board (2/3) − ..................... 54
7-22. Schematic Diagram − DSP Board (3/3) − ..................... 55
7-23. Printed Wiring Board
− DSP Board (Component Side) − ................................ 56
7-24. Printed Wiring Board
− DSP Board (Conductor Side) − .................................. 57
7-25. Printed Wiring Board − MC Board − ............................. 58
7-26. Schematic Diagram − MC Board − ................................ 59
7-27. Printed Wiring Board
− FRONT REAR AMP Board − ..................................... 60
7-28. Schematic Diagram
− FRONT REAR AMP Board − ..................................... 61
7-29. Printed Wiring Board
− CENTER SW AMP Board − ...................................... 62
7-30. Schematic Diagram
− CENTER SW AMP Board − ....................................... 63
7-31. Printed Wiring Boards − SPEAKER Section −............. 64
7-32. Schematic Diagram − REGULATOR Board − ............. 65
7-33. Schematic Diagram − SP RELAY Board (1/2) − .......... 66
7-34. Schematic Diagram − SP RELAY Board (2/2) − .......... 67
7-35. Printed Wiring Board − GC Board − ............................. 68
7-36. Schematic Diagram − GC Board − ................................ 69
7-37. Printed Wiring Boards − CHANGER Section − ........... 70
7-38. Schematic Diagram − CHANGER Section −................ 71
7-39. Printed Wiring Boards − CD DOOR Section −............. 72
7-40. Schematic Diagram − CD DOOR Section − ................. 73
7-41. Printed Wiring Boards − PANEL Section − .................. 74
7-42. Schematic Diagram − PANEL Section − ...................... 75
7-43. Printed Wiring Board − MIC Board − ........................... 76
7-44. Schematic Diagram − MIC Board − .............................. 77
7-45. Printed Wiring Board − VIDEO Board − ...................... 78
7-46. Schematic Diagram − VIDEO Board − ......................... 79
7-47. Printed Wiring Board − TRANS Board − ..................... 80
7-48. Schematic Diagram − TRANS Board − ........................ 81
7-49. Printed Wiring Board − SUB TRANS Board − ............ 82
7-50. Schematic Diagram − SUB TRANS Board − ............... 83
8 EXPLODED VIEWS
8-1. Cover Section .................................................................118
8-2. Mechanical (Cassette) Deck Section .............................119
8-3. CD MOTOR/CD DOOR SW1/MIC/PANEL (U)/
TC DOOR/TC DOOR SW Boards Section ................... 120
8-4. Moving Panel Section ....................................................121
8-5. Front Panel Section ........................................................ 122
8-6. DSP/GC/MC/MB/REGULATOR Boards Section ........123
8-7. Power Tansformer Section .............................................124
8-8. CENTER SW AMP/FRONT REAR AMP
Boards Section ............................................................... 125
8-9. SP RELAY Board Section .............................................126
8-10. DVD Mechanism Deck Section-1
(CDM53N-DVBU14).....................................................127
8-11. DVD Mechanism Deck Section-2
(CDM53N-DVBU14)..................................................... 128
8-12. DVD Mechanism Deck Section-3
(CDM53N-DVBU14)..................................................... 129
8-13. DVD Mechanism Deck Section-4
(CDM53N-DVBU14)..................................................... 130
8-14. Base Unit Section (DVBU14)........................................ 131
9. ELECTRICAL PARTS LIST .............................. 132
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
To Next Page
Loading...
Need help?
General
