• Do
not mix different types of antifreeze. The
mixture can produce a chemical reaction
causing harmful substances or vapors.
• Antifreeze is extremely flammable and
explosive under certain conditions. Keep fire
and children away from the antifreeze.
• When draining fluids from the engine, collect
fluids with a some container underneath the
engine body.
• Do not pour waste onto the grounds, down a
drain, or into any water source.
• Follow the relevant environmental-protection-
regulations when disposing of the antifreeze.
• Antifreeze if swallowed is poisonous to people,
animals, and birds.
1. Park the machine on a firm, flat and, level surface.
2. Lower the lift arms to the ground.
3. Stop the engine
4. Then remove the key and wait until the engine has
cooled down completely.
1. Tilt the radiator.
2. Open the drain plug on the bottom of the radiator
and drain coolant completely. if a recovery tank is
equipped, disconnect the line from the tank floor
and then open the drain shutoff-valve.
3. To clean, rinse the radiator with water.
4. Close the drain plug and fill the radiator and the
recovery tank with coolant fluid.
5. Let the engine idle for about five min..
6. Stop the engine and remove the key.
7. Check the coolant level of recovery tank and add
the coolant if necessary.
The machine has been shipped filled with 50%
antifreeze solution.
(1) Drain plug
(2)
Radiator cap
(3) Recovery tank
(A) FULL
(B) LOW
Cooling water 9.5 L
IMPORTANT :
•
Do not operate the engine without coolant.
• To fill the radiator system and the recovery
tank, use fresh water and antifreeze fluid.
• When the antifreeze is mixed with water, the
antifreeze mixing ratio must be less than
50%.
• Tighten the radiator cap properly. If the cap
is loosely or not properly fitted, overheating
of the engine can result due to coolant fluid
loss.
2. Replacing the fuel hose
1. Replace
the hoses and clamps according to
Checking the fuel line and the intake air line on
page 96.
(1) Fuel lines
MAINTENANCE BIENNIAL SERVICING
To Next Page
Loading...
Need help?
General
