2
9926813 R04 - 2013-2016 RZR 570 Service Manual
© Copyright Polaris Industries Inc.
2.19
FUEL SYSTEM AND AIR INTAKE
FUEL SYSTEM
WARNING
Gasoline is extremely flammable and explosive under
certain conditions.
Always stop the engine and refuel outdoors or in a well
ventilated area.
Do not smoke or allow open flames or sparks in or near
the area where refueling is performed or where
gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water and
change clothing.
Never start the engine or let it run in an enclosed area.
Engine exhaust fumes are poisonous and can result in
loss of consciousness or death in a short time.
Never drain the fuel when the engine is hot. Severe
burns may result.
FUEL LINE
1. Check the quick-connect fuel line
q
from the engine
fuel rail connection to the fuel tank connection for
signs of wear, deterioration, damage or leakage.
Replace if necessary.
2. Be sure fuel line is routed and retained properly.
NOTE
Make sure line is not kinked or pinched.
3. Replace fuel line every two years.
FUEL PUMP / FUEL FILTERS
The RZR 570 engine uses a serviceable, high-volume,
high-pressure, fuel pump that includes a preliminary filter
and an internal fine filter located before the pump
regulator.
NOTE
Neither filter is servicable individually. Must replace the
fuel pump as an assembly.
Refer to Chapter 4 for fuel pump replacement and all
other information related to the EFI System.
MAINTENANCE
To Next Page
Loading...
Need help?
General
