Yamaha F115 - Installation Requirements and Warnings

Specifications and requirements
20
Total engine oil quantity (oil pan capacity):
F115A 4.3 L (4.55 US qt, 3.78 Imp.qt)
F115AET1 4.3 L (4.55 US qt,
3.78 Imp.qt)
F150AET1 5.2 L (5.50 US qt,
4.58 Imp.qt)
F150TR 5.2 L (5.50 US qt, 4.58 Imp.qt)
FL115AET1 4.3 L (4.55 US qt,
3.78 Imp.qt)
FL150AET1 5.2 L (5.50 US qt,
4.58 Imp.qt)
LF115A 4.3 L (4.55 US qt, 3.78 Imp.qt)
LF150TR 5.2 L (5.50 US qt, 4.58 Imp.qt)
Lubrication:
Wet sump
Recommended gear oil:
Hypoid gear oil SAE#90
Gear oil quantity:
F115A 0.760 L (0.803 US qt,
0.669 Imp.qt)
F115AET1 0.760 L (0.803 US qt,
0.669 Imp.qt)
F150AET1 0.980 L (1.036 US qt,
0.862 Imp.qt)
F150TR 0.980 L (1.036 US qt,
0.862 Imp.qt)
FL115AET1 0.715 L (0.756 US qt,
0.629 Imp.qt)
FL150AET1 0.870 L (0.920 US qt,
0.766 Imp.qt)
LF115A 0.715 L (0.756 US qt,
0.629 Imp.qt)
LF150TR 0.870 L (0.920 US qt,
0.766 Imp.qt)
Tightening torque for engine:
Spark plug:
25.0 Nm (2.55 kgf-m, 18.4 ft-lb)
Propeller nut:
55.0 Nm (5.61 kgf-m, 40.6 ft-lb)
Engine oil drain bolt:
28.0 Nm (2.86 kgf-m, 20.7 ft-lb)
Engine oil filter:
18.0 Nm (1.84 kgf-m, 13.3 ft-lb)
EMU33554
Installation requirements
EMU33564
Boat horsepower rating
WARNING
EWM01560
Overpowering a boat can cause severe in-
stability.
Before installing the outboard motor(s), con-
firm that the total horsepower of your out-
board motor(s) does not exceed the boats
maximum horsepower rating. See the boat’s
capacity plate or contact the manufacturer.
EMU33571
Mounting motor
WARNING
EWM01570
●
Improper mounting of the outboard mo-
tor could result in hazardous conditions
such as poor handling, loss of control,
or fire hazards.
●
Because the motor is very heavy, spe-
cial equipment and training is required
to mount it safely.
Your dealer or other person experienced in
proper rigging should mount the motor using
correct equipment and complete rigging in-
structions. For further information, see page
60.
EMU42072
Yamaha Security System (if equipped)
NOTICE
ECM02460
The Yamaha Security System is sold in
conformity with the relevant laws and reg-
ulations regarding radio wave transmis-
sion. Therefore, if this product is used
outside the country where it was sold, it
may violate the laws or regulations regard-
U63P1DE0.book Page 20 Tuesday, March 29, 2011 7:15 PM
©2019 Yamaha Motor Corporation, U.S.A.