Maintenance chart
Correct maintenance is fundamental for ensuring the longevity of your vehicle and maintaining optimum
function and performance.
To this end, Aprilia offers a set of checks and maintenance services (at the owner's expense), that are
summarised in the table shown on the following page. Any minor faults must be reported without delay
to an Authorised Aprilia Dealer or Sub-Dealer without waiting until the next scheduled service to
solve it.
All scheduled services must be carried out at the specified intervals and mileage, as soon as the pre-
determined mileage is reached. Carrying out scheduled services on time is essential for the validity of
your warranty. For further information regarding Warranty procedures and ''Scheduled Maintenance'',
please refer to the ''Warranty Booklet''.
NOTE
CARRY OUT MAINTENANCE OPERATIONS AT HALF THE INTERVALS SPECIFIED IF THE VE-
HICLE IS USED IN PARTICULAR RAINY OR DUSTY CONDITIONS, OFF ROAD OR FOR TRACK
USE.
I: INSPECT AND CLEAN, ADJUST, LUBRICATE OR REPLACE IF NECESSARY
C: CLEAN, R: REPLACE, A: ADJUST, L: LUBRICATE, G: CLOSE, B: RECHARGE
(1) Lubricate every 500 km (310.68 mi)
(2) Check every 3,000 km (3,728.23 mi) / Replace every 12,000 km (7,456.45 mi)
(3) Check every 6,000 km (3,728.23 mi) / Replace every 20,000 km (12,427.42 mi)
(4) Grease every 2 years or 20,000 Km (12,427.42 mi)
(5) Charge the battery once a month if the vehicle is unused
ROUTINE MAINTENANCE TABLE
km (mi) x 1,000
0.5
(0.31)
3 (1.86) 6 (3.73) 9 (5.59) 12
(7.46)
15
(9.32)
18
(11.18)
Rear shock absorber I I I I I I I
Battery (5) I-B I-B I-B I-B I-B I-B I-B
Safety fasteners G G G G G G G
Spark plug - - I-C - I-C - I-C
Rear brake cam (4) - - - - - - -
Depression carburettor I - I - I - I
Timing chain - - I-A - I-A - I-A
Drive chain (1) I I I I I I I
Transmission cables and controls A - A-C - A-C - A-C
Wheels/tyres I I I I I I I
Fluid loss check C C C C C C C
Front/rear wheel bearings (4) - - - - - - -
Steering bearings (4) - - - - - - -
Air filter C C C C C C C
Fuel filter (2) C C C C R C C
Engine oil filter C C C C C C C
Rear brake A A A A A A A
Clutch I I I I I I I
Valve clearance - - I-A - I-A - I-A
Light circuit I I I I I I I
Stop light switch I-A I-A I-A I-A I-A I-A I-A
Brake fluid (3) I - I - I - I
Motor oil R R R R R R R
Maintenance ETX - STX 150
MAIN - 26
To Next Page
Loading...
Need help?
General
