To Next Page

To Previous Page

20 STORAGE

140

Info

Avoid running the engine for a short time only. Since

the engine cannot warm up properly, the water vapor

produced during combustion condenses and causes

valves and the exhaust system to rust.

20.2 Preparing for use after storage

401059-01

– Remove the motorcycle from the lift stand. ( p. 54)

– Install the 12-V battery. ( p. 109)

– Perform checks and maintenance measures when preparing

for use. ( p. 36)

– Take a test ride.

Default Chapter4
- Table of Contents4
1 Means of Representation8
- Symbols Used8
- Formats Used8
2 Safety Advice 29
- Use Definition - Intended Use9
- Misuse9
- Degrees of Risk and Symbols10
- Tampering Warning10
- Safe Operation10
- Protective Clothing11
- Work Rules11
- Environment12
- Owner's Manual12
3 Important Notes 313
- Manufacturer Warranty, Implied Warranty13
- Fuel, Auxiliary Substances13
- Spare Parts, Accessories13
- Service13
- Figures13
- Customer Service14
4 View of Vehicle 415
- View of Vehicle, Front Left (Example)15
- View of Vehicle, Rear Right (Example)16
5 Serial Numbers 517
- Vehicle Identification Number17
- Type Label (FE EU)17
- Key Number (FE EU)17
- Engine Number17
- Fork Part Number18
- Shock Absorber Article Number18
6 Controls 619
- Clutch Lever19
- Hand Brake Lever19
- Throttle Grip19
- Stop Button19
- Horn Button (FE EU)20
- Light Switch (FE EU)20
- Light Switch (FE US)20
- Turn Signal Switch (FE EU)21
- Emergency off Switch (FE EU)21
- Start Button21
- Combination Switch22
- Overview of Indicator Lamps (FE EU)22
- Overview of Indicator Lamps (FE US)23
- Opening Fuel Tank Filler Cap23
- Closing the Fuel Tank Filler Cap24
- Cold Start Button24
- Idle Speed Adjusting Screw25
- Shift Lever25
- Foot Brake Lever26
- Side Stand26
- Steering Lock (FE EU)26
- Locking the Steering (FE EU)27
- Unlocking the Steering (FE EU)27
7 Combination Instrument28
- Combination Instrument28
- Combination Instrument Overview28
- Activation28
- Message on the Combination Instrument28
- Setting the Combination Instrument28
- Adjusting the Kilometers or Miles29
- Adjusting the Clock30
- Setting the Service Display30
- Speed, Time, and DST Distance 131
- Speed, Time, and DST2 Distance 231
- AVG Average Speed, ART Operating Hours, and ODO Total Distance Covered32
8 Preparing for Use 833
- Advice on Preparing for First Use33
- Running-In the Engine34
- Starting Power of Lithium-Ion Batteries at Low Temperatures35
- Preparing the Vehicle for Difficult Operating Conditions35
- Preparing the Vehicle for Riding on Dry Sand35
- Preparing the Vehicle for Riding on Wet Sand36
- Preparing the Vehicle for Riding on Wet and Muddy Circuits36
- Preparing Vehicle for High Temperatures or Slow Riding37
- Preparing the Vehicle for Low Temperatures or Snow37
9 Riding Instructions38
- Checks and Maintenance Measures When Preparing for Use38
- Starting the Vehicle38
- Activating Traction Control39
- Starting off40
- Shifting, Riding40
- Braking40
- Stopping, Parking41
- Transporting42
- Refueling42
10 Service Schedule44
- Additional Information44
- Required Work44
- Recommended Work45
11 Tuning the Chassis 1147
- Checking the Basic Chassis Setting with Rider's Weight47
- Compression Damping of the Shock Absorber47
- Adjusting the Low-Speed Compression Damping of the Shock Absorber47
- Adjusting the High-Speed Compression Damping of the Shock Absorber48
- Adjusting the Rebound Damping of the Shock Absorber49
- Measuring the Dimension of the Rear Wheel Unloaded49
- Checking the Static Sag of the Shock Absorber50
- Checking the Riding Sag of the Shock Absorber50
- Adjusting the Spring Preload of the Shock Absorber51
- Adjusting the Riding Sag52
- Checking the Basic Setting of the Fork52
- Adjusting the Compression Damping of the Fork53
- Adjusting the Rebound Damping of the Fork53
- Adjusting the Spring Preload of the Fork54
- Handlebar Position54
- Adjusting the Handlebar Position55
12 Service Work on the Chassis56
- Raising the Motorcycle with a Lift Stand56
- Removing the Motorcycle from the Lift Stand56
- Bleeding the Fork Legs56
- Cleaning the Dust Boots of the Fork Legs57
- Removing the Fork Protector57
- Installing the Fork Protector58
- Removing the Fork Legs58
- Installing the Fork Legs59
- Removing the Lower Triple Clamp59
- Installing the Lower Triple Clamp60
- Checking Steering Head Bearing Play62
- Adjusting the Steering Head Bearing Play63
- Lubricating the Steering Head Bearing64
- Removing Front Fender64
- Installing Front Fender65
- Removing the Shock Absorber65
- Installing the Shock Absorber67
- Removing the Seat68
- Mounting the Seat69
- Removing the Air Filter Box Cover70
- Installing the Air Filter Box Cover70
- Removing the Air Filter70
- Installing the Air Filter71
- Cleaning the Air Filter and Air Filter Box71
- Removing the Right Side Cover72
- Installing the Right Side Cover73
- Removing the Main Silencer73
- Installing the Main Silencer74
- Cleaning the Spark Arrestor (FE US)74
- Changing the Glass Fiber Yarn Filling in the Main Silencer76
- Removing the Fuel Tank77
- Installing the Fuel Tank79
- Checking for Chain Dirt Accumulation80
- Cleaning the Chain81
- Checking the Chain Tension81
- Adjusting the Chain Tension82
- Checking the Chain, Rear Sprocket, Engine Sprocket, and Chain Guide83
- Checking the Frame86
- Checking the Link Fork86
- Checking the Throttle Cable Routing86
- Checking the Rubber Grip87
- Adjusting the Basic Position of the Clutch Lever88
- Checking/Correcting the Fluid Level of Hydraulic Clutch88
- Changing the Hydraulic Clutch Fluid89
- Removing the Engine Guard90
- Installing the Engine Guard90
13 Brake System 1391
- Adjusting the Basic Position of the Hand Brake Lever91
- Checking the Brake Discs91
- Checking the Front Brake Fluid Level92
- Adding the Front Brake Fluid92
- Checking the Front Brake Linings93
- Changing the Front Brake Linings94
- Checking the Free Travel of Foot Brake Lever96
- Adjusting the Basic Position of the Foot Brake Lever97
- Checking the Rear Brake Fluid Level97
- Adding Rear Brake Fluid98
- Checking the Rear Brake Linings99
- Changing the Rear Brake Linings99
14 Wheels, Tires 14103
- Removing the Front Wheel103
- Installing the Front Wheel104
- Removing the Rear Wheel105
- Installing the Rear Wheel106
- Checking the Tire Condition108
- Checking Tire Pressure108
- Checking Spoke Tension109
15 Electrical System110
- Removing the 12-V Battery110
- Installing the 12-V Battery111
- Charging the 12-V Battery113
- Changing Main Fuse114
- Changing the Fuses of Individual Electrical Power Consumers115
- Removing the Headlight Mask with the Headlight117
- Installing the Headlight Mask with the Headlight117
- Changing the Headlight Bulb119
- Changing the Turn Signal Bulb (FE EU)119
- Checking the Headlight Setting120
- Adjust the Headlight Range121
- Changing the Combination Instrument Battery121
- Diagnostics Connector122
16 Cooling System 16123
- Checking the Antifreeze and Coolant Level123
- Checking the Coolant Level124
- Draining the Coolant124
- Refilling with Coolant125
- Changing the Coolant126
17 Tuning the Engine 17127
- Checking the Play in the Throttle Cable127
- Adjusting the Play in the Throttle Cable127
- Adjusting the Characteristic Map of the Throttle Response128
- Changing the Mapping130
- Adjusting the Idle Speed130
- Programming the Throttle Valve Position131
- Checking the Basic Position of the Shift Lever132
- Adjusting the Basic Position of the Shift Lever132
18 Service Work on the Engine 18133
- Changing the Fuel Screen133
- Checking the Engine Oil Level135
- Changing the Engine Oil and Oil Filter, Cleaning the Oil Screen135
- Adding Engine Oil138
19 Cleaning, Care 19139
- Cleaning the Motorcycle139
- Checks and Maintenance Steps for Winter Operation140
20 Storage 20141
- Preparing for Use after Storage142
21 Troubleshooting 21143
22 Blink Code146
23 Technical Data148
- Engine148
- Engine Tightening Torques149
- Capacities151
- Engine Oil151
- Coolant151
- Fuel151
- Chassis151
- Electrical System152
- Tires153
- Fork153
- Shock Absorber153
- Chassis Tightening Torques154
24 Substances 24157
25 Auxiliary Substances 25159
26 Standards 26161
27 Index of Special Terms162
28 List of Abbreviations 28163
29 List of Symbols164
- Yellow and Orange Symbols164
- Green and Blue Symbols164
- Index165

Brand	Husqvarna
Model	FE 350 2021
Category	Motorcycle
Language	English

Husqvarna FE 350 2021 User Manual

Table of Contents

Questions and Answers:

Husqvarna FE 350 2021 Specifications

Related product manuals