To Next Page

To Previous Page

SERVICE WORK ON THE CHASSIS 13

257

A00668-11

–

Remove screw

with the washer.

– Take off the main silencer.

Info

Both the accessory main silencer as well as the

original main silencer are included in the scope of

supply.

13.36 Installing the main silencer

A00683-10

(890 ADVENTURE R)

– Position the main silencer with the gasket.

–

Mount screw

with the washer, but do not tighten yet.

Guideline

Screw, main

silencer holder

M8 25 Nm

(18.4 lbf ft)

Default Chapter5
- Table of Contents5
1 Means of Representation 113
- Symbols Used13
- Formats Used14
2 Safety Advice 215
- Use Definition - Intended Use15
- Misuse15
- Degrees of Risk and Symbols16
- Overview of Labels18
- Reporting Safety Defects24
- Noise Emission Warranty25
- Operating Noise Warning25
- Manufacturer Warranty for the Exhaust Monitoring System25
- Consumer Rights26
- Tampering Warning27
- Safe Operation28
- Protective Clothing29
- Work Rules29
- Environment30
- Owner's Manual30
3 Important Notes32
- Manufacturer Warranty, Implied Warranty32
- Fuel, Auxiliary Substances32
- Spare Parts, Technical Accessories32
- Service33
- Figures33
- Customer Service33
4 View of Vehicle34
- View of Vehicle, Front Left (Example)34
- View of Vehicle, Rear Right (Example)36
5 Serial Numbers38
- Vehicle Identification Number38
- Type Label39
- Key Number40
- Engine Number40
- Fork Part Number41
- Shock Absorber Article Number41
- Steering Damper Article Number42
6 Controls 643
- Clutch Lever43
- Hand Brake Lever43
- Throttle Grip44
- Switches on the Left Side of the Handlebar44
- Combination Switch44
- Light Switch45
- Cruise Control System Tip Switch46
- Menu Buttons49
- Turn Signal Switch50
- Horn Button51
- Switches on the Right Side of the Handlebar51
- Start Button/Emergency off Switch51
- Ignition and Steering Lock52
- Locking the Steering53
- Unlocking the Steering54
- Socket for Electrical Accessories54
- Opening the Fuel Tank Filler Cap55
- Closing the Fuel Tank Filler Cap57
- Fuel Cocks58
- Opening the Storage Compartment on the Left58
- Closing the Storage Compartment on the Left60
  - Opening the Storage Compartment on the Right61
  - Closing the Storage Compartment on the Right62
  - Tool Set63
  - Grab Handles63
  - Luggage Rack Plate64
  - Seat Lock65
  - Passenger Foot Pegs65
  - Shift Lever66
  - Foot Brake Lever67
  - Side Stand67
7 Combination Instrument 769
- Activation and Test69
- Day-Night Mode71
- Warnings72
- Ice Warning72
- Indicator Lamps74
- Display78
- Rally Display (Optional)82
- Speed83
- Shift Warning Light84
- Speedometer85
- Heated Grip (Optional)86
- Seat Heater (Optional)86
- Ride Display87
- ABS Display87
- MTC Display88
- Cruise Control Indicator (Optional)88
- Coolant Temperature Indicator89
- Fuel Level Display90
- Ambient Air Temperature Indicator92
- Time92
- Favorites Display93
- Quick Selector 1 Display93
- Quick Selector 2 Display94
- Navigation Display94
- Menu95
- Ktm My Ride95
- Audio96
- Navigation98
- Pairing99
- Phone100
- Headset103
- Telephony105
- Trips/Data106
- General Info107
- Trip 1108
- Trip 2109
- TPMS (Function Optional)110
- 7.26.13 Warning111
- 7.26.14 Ride Mode112
- Ride Mode113
- Rally (Optional)115
- Throttle Response (Optional)116
- Leave Rally (Optional)117
- 7.26.19 Motorcycle118
- 7.26.20 Mtc119
- MTC+MSR (Optional)120
- 7.26.22 Abs122
- Heating Grip (Function Optional)123
- Heating Seat Rider (Function Optional)124
- Quick Shift+ (Optional)125
- 7.26.26 Settings125
- 7.26.27 Favorites126
- Quick Selector 1127
- Quick Selector 2128
- 7.26.30 Bluetooth129
- 7.26.31 Display Theme130
- 7.26.32 Shift Light131
- 7.26.33 Rpm1131
- 7.26.34 Rpm2132
- 7.26.35 Shift Light133
- 7.26.36 Setting the Time and Date133
  - 7.26.37 Drl136
  - 7.26.38 Units138
  - 7.26.39 Distance138
  - 7.26.40 Temperature139
  - 7.26.41 Fuel Cons139
  - 7.26.42 Language140
  - Heating (Optional Function)141
  - Heating Grip (Function Optional)142
  - Heating Seat Rider (Optional Function)143
  - Heating Seat Pillion (Function Optional)144
  - 7.26.47 Service145
  - 7.26.48 Extra Functions146
8 Ergonomics 8147
- Handlebar Position147
- Adjusting the Handlebar Position147
- Adjusting the Windshield150
- Adjusting the Basic Position of the Clutch Lever152
- Adjusting the Basic Position of the Hand Brake Lever153
- Adjusting Foot Brake Lever Stub154
- Adjusting the Basic Position of the Foot Brake Lever155
- Checking the Basic Position of the Shift Lever157
- Adjusting the Basic Position of the Shift Lever158
9 Preparing for Use160
- Advice on Preparing for First Use160
- Running in the Engine162
- Loading the Vehicle163
10 Riding Instructions166
- Checks and Maintenance Measures When Preparing for Use166
- Starting the Vehicle167
- Starting off168
- Quickshifter + (Optional)169
- Shifting, Riding170
- MSR (Optional)176
- Applying the Brakes177
- Stopping, Parking179
- Transporting181
- Refueling182
11 Service Schedule 11185
- Additional Information185
- Required Work185
- Recommended Work188
12 Tuning the Chassis 12189
- Fork/Shock Absorber189
- Adjusting the Compression Damping of the Fork189
- Adjusting the Rebound Damping of the Fork192
- Adjusting the Spring Preload of the Fork194
- Bleeding the Fork Legs (890 ADVENTURE R RALLY)196
- Compression Damping of the Shock Absorber197
- Adjusting the Low-Speed Compression Damping of the Shock Absorber198
- Adjusting the High-Speed Compression Damping of the Shock Absorber200
- Adjusting the Rebound Damping of the Shock Absorber203
- Adjusting the Spring Preload of the Shock Absorber205
13 Service Work on the Chassis 13209
- Raising the Motorcycle with Rear Lifting Gear209
- Removing the Rear of the Motorcycle from the Lifting Gear209
- Lifting the Motorcycle with the Front Lifting Gear210
- Taking the Motorcycle off the Front Lifting Gear211
- Removing the Seat212
- Mounting the Seat213
- Checking for Chain Dirt213
- Cleaning the Chain214
- Checking the Chain Tension216
- Adjusting the Chain Tension218
- Checking the Chain, Rear Sprocket, Engine Sprocket, and Chain Guide220
- Removing the Left Side Cover224
- Installing the Left Side Cover225
- Removing the Right Side Cover226
- Installing the Right Side Cover227
- Removing the Battery Cover228
- Installing the Battery Cover229
- Removing Left Fuel Tank Spoiler230
- Installing the Left Fuel Tank Spoiler233
- Removing Right Fuel Tank Spoiler235
- Installing the Right Fuel Tank Spoiler238
- Removing the Front Fender240
- Installing the Front Fender241
- Mount Screws , but Do Not Tighten yet241
- Guideline241
- Removing Fork Protector242
- Installing the Fork Protector242
- Mount Screw 5 , but Do Not Tighten yet242
- Cleaning the Dust Boots of the Fork Legs243
- Removing the Windshield246
- Installing the Windshield247
- Removing Left Fuel Tank Cover248
- Installing the Left Fuel Tank Cover249
- Guideline Screw, Fuel Tank M6249
- Guideline249
- Screw, Fuel Tank M6249
- Removing Right Fuel Tank Cover251
- Installing the Right Fuel Tank Cover252
- Removing Engine Guard253
- Installing the Engine Guard255
- Removing the Main Silencer257
- Installing the Main Silencer259
14 Brake System264
- Anti-Lock Braking System (ABS)264
- Checking Brake Discs267
- Checking the Front Brake Fluid Level268
- Adding Front Brake Fluid269
- Checking the Front Brake Linings272
- Checking the Free Travel of the Foot Brake Lever273
- Checking the Rear Brake Fluid Level274
- Adding Rear Brake Fluid275
- Checking the Rear Brake Linings278
15 Wheels, Tires 15279
- Removing the Front Wheel279
- Installing the Front Wheel284
- Removing the Rear Wheel292
- Installing the Rear Wheel295
- Checking the Rear Hub Damping Rubber Pieces298
- Checking the Tire Condition300
- Checking Tire Pressure302
- Checking Spoke Tension304
- Tubeless Tire System305
- Using Tire Repair Spray306
16 Electrical System 16307
- Daytime Running Light (DRL)307
- Removing the 12-V Battery308
- Installing the 12-V Battery312
- Charging the 12-V Battery315
- Changing the Main Fuse318
- Changing the ABS Fuses321
- Changing the Fuses of Individual Electrical Power Consumers323
- Changing the Turn Signal Bulb325
- Checking the Headlight Setting327
- Adjusting the Headlight Range328
- Diagnostics Connector330
- Front ACC1 and ACC2330
- ACC1 and ACC2 Rear331
17 Cooling System332
- Checking the Coolant Level in the Compensating Tank333
- Correcting the Coolant Level in the Compensating Tank334
18 Tuning the Engine 18337
- Ride Mode337
- Motorcycle Traction Control (Cornering MTC)338
- Slip Adjustment (Optional)339
- Throttle Response (Optional)340
19 Service Work on the Engine 19341
- Checking the Engine Oil Level341
- Changing the Engine Oil and Oil Filter, Cleaning the Oil Screens342
- Adding Engine Oil346
- Checking the Free Travel of the Clutch Lever348
- Setting the Free Travel of the Clutch Lever349
20 Cleaning, Care350
- Cleaning the Motorcycle350
- Checks and Maintenance Steps for Winter Operation353
21 Storage 21355
- Preparing for Use after Storage356
22 Troubleshooting 22357
23 Technical Data 23361
- Engine361
- Engine Tightening Torques363
- Capacities369
- Engine Oil369
- Coolant369
- Fuel369
- Chassis369
- Electrical System372
- Tires373
- Fork373
- Adventure R373
- Adventure R Rally374
- Shock Absorber376
- Adventure R376
- Adventure R Rally377
- Chassis Tightening Torques379
24 Declarations of Conformity 24389
- Country-Specific Declarations of Conformity392
25 Substances 25393
26 Auxiliary Substances396
27 Standards398
28 Index of Special Terms 28399
- List of Abbreviations400
29 List of Abbreviations401
30 List of Symbols401
- Red Symbols401
- Yellow and Orange Symbols401
- Green and Blue Symbols402
- Index403

Brand	KTM
Model	890 Adventure R US 2021
Category	Motorcycle
Language	English

KTM 890 Adventure R US 2021 User Manual

Table of Contents

Questions and Answers:

KTM 890 Adventure R US 2021 Specifications

Related product manuals