KTM 85 SX 19/16 2017 User Manual

11 SERVICE WORK ON THE CHASSIS 41
11.22 Removing the air filter box cover
H01370-10
–
Pull off the air filter box cover in area

sideways and remove it toward the front.
11.23 Installing the air filter box cover
H01370-11
–
Insert the air filter box cover into rear area

and clip it into front area

.
11.24 Removing the air filter
Note
Engine damage Unfiltered intake air has a negative effect on the service life of the engine.
Dust and dirt will enter the engine without an air filter.
– Never start to use the vehicle without an air filter.
Warning
Environmental hazard Hazardous substances cause environmental damage.
– Dispose of oils, grease, filters, fuel, cleaning agents, brake fluid, etc., correctly and in compliance with the applicable regu-
lations.
Preparatory work
– Remove the air filter box cover. ( p. 41)
H01371-10
Main work
–
Unhook air filter holder

and swing it to the side. Remove the air filter with the
air filter support.
– Remove the air filter from the air filter support.
11.25 Cleaning the air filter and air filter box
Warning
Environmental hazard Hazardous substances cause environmental damage.
– Dispose of oils, grease, filters, fuel, cleaning agents, brake fluid, etc., correctly and in compliance with the applicable regu-
lations.
Info
Do not clean the air filter with fuel or petroleum since these substances attack the foam.

KTM 85 SX 19/16 2017 Specifications

General

Engine Type	1-cylinder, 2-stroke engine
Displacement	84.9 cm³
Starter	Kickstarter
Transmission	6-speed
Clutch	Wet, multi-disc clutch, Formula hydraulics
Front Wheel	1.60 x 19"
Rear Wheel	2.15 x 16"
Seat Height	890 mm
Cooling System	Liquid cooled
Bore x Stroke	47 mm x 48.95 mm
Frame	Central tube frame, chrome molybdenum steel
Front Suspension	WP upside-down Ø 43 mm
Rear Suspension	WP monoshock
Front Brake	Disc brake
Rear Brake	Disc brake
Wheelbase	1, 290 mm ± 10 mm
Tank Capacity	5.2 liters