2.10
9850060 R02 - 2020-2021 850 AXYS™ Long Track Snowmobile Service Manual
© Copyright Polaris Inc.
PERIODIC MAINTENANCE CHART
The maintenance interval charts outline required maintenance and inspection based on vehicle miles. Each table
states the number miles that service is required on the vehicle. Some items or components may need to be serviced
more often due to severe use or riding conditions. When the vehicle goes beyond 2000 miles (3200 km), continue
maintenance checks at 2000 miles (3200 km) intervals.
150 MILES (240 KM) SERVICE
XU - PERFORM THESE PROCEDURES MORE OFTEN FOR VEHICLES SUBJECTED TO SEVERE USE.
D - HAVE AN AUTHORIZED POLARIS DEALER PERFORM THESE SERVICES.
E - EMISSION CONTROL SYSTEM SERVICE.
CODE ITEM ACTION
QUICKDRIVE Belt (If Equipped) Inspect or Adjust
Drive / Driven Clutch Condition
Inspect or Adjust
50/50 Extended Life Coolant
Replace every 5 years
60/40 Coolant (If applicable) Replace every 2 years
Throttle Lever / Throttle Cable
Inspect or Adjust
Air Box
Inspect or Adjust
Hood / Side Panel Fasteners
Inspect or Adjust
Drive Chain Tension (If Equipped) Inspect or Adjust
Chaincase Oil (If Equipped) Inspect or Adjust
Track Alignment / Track Tension Inspect or Adjust
Front Limiter Strap Inspect or Adjust
Rail Slide Condition
Inspect or Adjust
Bogie / Wheel Condition / Fastener
Bolts
Inspect or Adjust
Rear Idler Wheel Bolts
Inspect or Adjust
Rear Idler Adjuster Bolt Jam Nuts Inspect or Adjust
500 MILES (800 KM) SERVICE
XU - PERFORM THESE PROCEDURES MORE OFTEN FOR VEHICLES SUBJECTED TO SEVERE USE.
D - HAVE AN AUTHORIZED POLARIS DEALER PERFORM THESE SERVICES.
E - EMISSION CONTROL SYSTEM SERVICE.
CODE ITEM ACTION
Clutch Alignment / Offset Inspect or Adjust
QUICKDRIVE Belt (If Equipped) Inspect or Adjust
Drive / Driven Clutch Condition Clean
Drive Belt Tension
Inspect or Adjust
Engine Mounts Inspect or Adjust
Recoil Handle / Rope / Function Inspect or Adjust
Cylinder Head Bolts Inspect or Adjust
Cylinder Base Nuts Inspect or Adjust
MAINTENANCE
To Next Page
Loading...
Need help?
General
