MAINTENANCE
2.3
MAINTENANCE AND LUBRICATION
Periodic Maintenance Chart
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles
(KM)
Steering - Pre-Ride - Check for free operation.

Front-suspension - Pre-Ride -
Make adjustments as needed. See Pre-
Ride Checklist on Page 2.8.

Rear-suspension - Pre-Ride -
Tires - Pre-Ride -
Engine Stop Switch - Check Operation

Brake fluid level - Pre-Ride -
Make adjustments as needed. See Pre-
Ride Checklist on Page 2.8

Brake lever travel - Pre-Ride -
Make adjustments as needed. See Pre-
Ride Checklist on Page 2.8
Brake systems - Pre-Ride -
Throttle - Pre-Ride - Check Operation
Wheels /fasteners - Pre-Ride -
Make adjustments as needed. See Pre-
Ride Checklist on Page 2.8
Frame Fasteners - Pre-Ride -

E
Engine oil level - Pre-Ride -
Make adjustments as needed. See Pre-
Ride Checklist on Page 2.8

E
Air filter, pre-filter - Daily - Inspect;clean often

E
Air box sediment tube - Daily - Drain deposits when visible
Coolant
(if applicable)
- Daily -
Check level daily, change coolant every 2
years
Headlamp/tail lamp - Daily -
Check operation; apply dielectric grease if
replacing

E
Air filter,
main element
- Weekly - Inspect; replace as needed
Recoil housing
(if equipped)
-Weekly -
Drain water as needed, check often if
operating in wet conditions


Brake pad wear 10 H Monthly 100 (160) Inspect periodically
Battery 20 H Monthly 200 (320) Check terminals; clean; test

E
Engine oil change
(break-in)
20 H 1M 100 (160)
Perform a break-in oil change at one
month

Front gearcase oil (if
equipped)
25 H Monthly 250 (400) Inspect level; change yearly

Middle gearcase oil (if
equipped)
25 H Monthly 250 (400) Inspect level; change yearly

Rear gearcase oil
(if equipped)
25 H Monthly 250 (400) Inspect level; change yearly

Transmission oil 25 H Monthly 250 (400) Inspect level; change yearly
Perform these procedures more often for vehicles subjected to severe use.
E Emission Control System Service (California)
 Have an authorized Polaris dealer perform these services.
To Next Page
Loading...
Need help?
General
