3-24 ENGINE CONTROL SYSTEM
LOW OIL PRESSURE CAUTION SYSTEM
CONDITION :
Immediate activation of system when the oil pressure switch turns “ON” due to an engine oil pressure drop
below 100 kPa (1.0 kg / cm
2
, 14 psi.).
Automatically reduced to approx. 3000 r/min. by intermittent fuel injection and ignition
signals if the system is activated at 3000 r/min. or higher.
“OIL” lamp lights continuously.
“REV-LIMIT” lamp lights continuously during engine speed rev-limiter activation.
Sounds in a series of long (1.5 sec.) beeps.
Engine speed
Caution lamp
Caution buzzer
ACTION :
RESET :
Stop engine and check engine oil level. Refill engine oil to the correct level if below the low oil mark.
If the engine oil level is correct, the following causes may be considered :
• Improper oil viscosity.
• Malfunctioning oil pressure switch.
• Clogged oil strainer or oil filter.
• Worn oil pump relief valve.
• Oil leakage from oil passage.
• Excessive wear / damage of oil pump.
NOTE:
The low oil pressure caution system is reset when the oil pressure is restored to over 1.0 kg/cm
2
with approx.
3000 r/min. or less engine speed operation.
However, the engine must be stopped and checked immediately once the system is activated.
To Next Page
Loading...
Need help?
General
