Operation Manual / A200-L
Table of contents
© Copyright 2021 ABB. All rights reserved. HZTL4036_EN Rev.T December 2021
Operation Manual / A200-L
1 Introduction............................................................................................................ 4
1.1 Essential information.................................................................................................... 5
1.2 Registered trademarks................................................................................................. 5
1.3 Layout and function of the turbocharger ................................................................ 6
1.4 Locations of the rating plates.................................................................................... 8
2 Safety ...................................................................................................................... 9
2.1 Introduction ................................................................................................................... 9
2.2 CE conformity................................................................................................................ 9
2.3 Definition of mandatory signs .................................................................................. 10
2.4 Definition of safety instructions .............................................................................. 10
2.5 Intended use ................................................................................................................. 11
2.6 Deflagration on gas engines ..................................................................................... 12
2.7 Warning plates on the turbocharger........................................................................ 13
2.8 Turbocharger rating plate.......................................................................................... 13
2.9 Periodic check of the pressure vessels.................................................................... 15
2.10 Lifting of loads ............................................................................................................. 16
2.11 Prerequisites for operation and maintenance....................................................... 17
2.12 Hazards during operation and maintenance ......................................................... 18
2.13 Safe operation............................................................................................................. 20
2.14 Safe maintenance ....................................................................................................... 20
3 Removal and installation .................................................................................... 26
3.1 Turbocharger weight ................................................................................................. 26
3.2 Removing the turbocharger...................................................................................... 26
3.3 Installing the turbocharger ...................................................................................... 28
4 Commissioning .................................................................................................... 31
4.1 Oil supply ....................................................................................................................... 31
4.2 Inspection procedures................................................................................................ 31
4.3 Commissioning after taking out of operation...................................................... 33
5 Monitoring during operation.............................................................................. 34
5.1 Oil pressure, oil temperature.................................................................................... 34
5.2 Admissible air inlet temperature .............................................................................. 37
5.3 Turbocharger speed .................................................................................................... 37
5.4 Low pressure measurement at the filter silencer ................................................ 40
6 Operation and service ......................................................................................... 41
6.1 Noise emission ............................................................................................................. 41
6.2 Service work................................................................................................................. 42
6.3 Expected replacement intervals .............................................................................. 46
6.4 Flexible turbocharger cut-out .................................................................................. 47
To Next Page
Need help?
General
