G-25
G2160, WSM
G GENERAL
5. When the specific gravity of electrolyte reaches 1.27 to 1.29,
charge has completed.
6. When exchanging an old battery with new one, use a battery of
equal specification shown in “SPECIFICATIONS”.
(For non-accessible maintenance-free type batteries.)
Maintenance-free, non-accessible batteries are designed to
eliminate the need to add water. Yet the volume of electrolyte
above plates may eventually become depleted due to abnormal
conditions such as high heat or improper regulator setting. Use
a voltmeter to check the state of charge. (See reference chart to
determine if charging is necessary.)
W1064359
[5] CHECK POINTS OF EVERY 150 HOURS
Changing Mower Gear Box Oil
1. See page G-18.
W1036280
[6] CHECK POINTS OF EVERY 200 HOURS
Changing Engine Oil Fiter Cartridge
1. See page G-18.
W1036341
Checking Radiator Hose and Clamp
• Check to see if the radiator hoses are properly fixed every
200 hours of operation or 6 months, whichever comes first.
1. If clamp bands (2) are loose or water leaks, tighten clamp band
(2) securely.
2. Replace radiator hoses (1) and tighten clamp bands (2) securely,
if radiator hoses (1) are swollen, hardened or cracked.
Repalce radiator hoses (1) and clamp bands (2) every 2 years or
earlier if checked and found that hoses are swollen, hardened or
cracked.
• Take the following actions in the event the coolant
temperature be nearly or more than the boiling point, what is
called “Overheating”.
• Park the machine in a safe place and keep the engine
unloaded idling.
• Don’t stop the engine suddenly, but stop it after about 5
minutes of unloaded idling
• Keep yourself well away from the machine for further 10
minutes or while the steam is belown out.
• Checking that there gets no danger such as burning, get rid
of the causes of overheating and then start the engine again.
W1036392
(1) Radiator Hose (2) Clamp Band
To Next Page
Loading...
Need help?
General
