To Next Page

To Previous Page

STORAGE 22

133

22.2 Preparing for use after storage

Info

If the Powerpack HV has not been used for more than six months, start by discharging the Powerpack HV

until the vehicle switches off with blink code 11. Then fully charge the Powerpack HV.

401059-01

– Remove the motorcycle from the lift stand. ( p. 57)

– Install the 12-V battery. ( p. 98)

– Install the Powerpack HV. ( p. 109)

– Perform checks and maintenance measures when preparing for

use. ( p. 40)

– Take a test ride.

Default Chapter4
- Table of Contents4
1 Means of Representation 17
- Symbols Used7
- Formats Used7
2 Safety Advice8
- Use Definition - Intended Use8
- Misuse8
- Degrees of Risk and Symbols8
- Safety Instructions and Warning Labels9
- Tampering Warning12
- Safe Operation12
- Fall or Accident12
- Protective Clothing13
- Work on the Vehicle, Motor, and Lithium-Ion Battery (Powerpack HV)13
- Environment13
- Owner's Manual14
- Fire Hazard14
3 Important Notes 315
- Manufacturer Warranty, Implied Warranty15
- Fuel, Auxiliary Substances15
- Spare Parts, Accessories15
- Service15
- Figures15
- Customer Service15
- Power Supply16
- New Powerpack HV16
- Operation at Low Temperatures16
4 View of Vehicle 417
- View of Vehicle, Front Left (Example)17
- View of Vehicle, Rear Right (Example)18
5 Serial Numbers 519
- Vehicle Identification Number19
- Type Label19
- Key Number19
- Motor Number19
- Fork Part Number20
- Shock Absorber Article Number20
- Battery Identification Number20
6 Controls 621
- Front Brake Lever21
- Rear Brake Lever21
- Throttle Grip21
- Main Switch21
- Start Button22
- Horn Button22
- Light Switch22
- Turn Signal Switch23
- Side Stand23
- Ignition Lock23
- Steering Lock24
- Locking the Steering24
- Unlocking the Steering24
7 Display25
- Display 725
- Multifunctional Element25
- Riding Mode Button25
- Driving Mode Display26
- Malfunction Indicator Lamp26
- Charge Level Indicator26
- Power Reduction27
- Overview28
- Overview of Indicator Lamps28
8 Combination Instrument 829
- Combination Instrument Overview29
- Activation and Test29
- Setting the Kilometers or Miles29
- Setting the Combination Instrument30
- Setting the Clock31
- Viewing the Lap Time31
- Display Mode SPEED (Speed)32
- Display Mode SPEED/H (Operating Hours)32
- Setup Menu32
- Adjusting the Unit of Measurement33
- Display Mode SPEED/CLK (Time)34
- Setting the Clock34
- Display Mode SPEED/LAP (Lap Time)34
- Viewing the Lap Time35
- Display Mode SPEED/ODO (Odometer)35
- Display Mode SPEED/TR1 (Trip Master 1)36
- Display Mode SPEED/TR2 (Trip Master 2)36
- Adjusting TR2 (Trip Master 2)36
- Display Mode SPEED/A1 (Average Speed 1)37
- Display Mode SPEED/A2 (Average Speed 2)37
- Display Mode SPEED/S1 (Stop Watch 1)38
- Display Mode SPEED/S2 (Stop Watch 2)38
- Table of Functions39
- Table of Conditions and Menu Activation40
9 Preparing for Use 941
- Advice on Preparing for First Use41
10 Riding Instructions42
- Checks and Maintenance Measures When Preparing for Use42
- Starting the Vehicle42
- Starting off44
- Recuperation44
- Applying the Brakes44
- Stopping, Parking45
- Deactivating the Vehicle45
- Transporting the Vehicle46
- Transporting Powerpack HV46
11 Service Schedule 1147
- Additional Information47
- Required Work47
- Recommended Work48
12 Tuning the Chassis 1249
- Checking the Basic Chassis Setting with the Rider's Weight49
- Compression Damping of the Shock Absorber49
- Adjusting the Low-Speed Compression Damping of the Shock Absorber49
- Adjusting the High-Speed Compression Damping of the Shock Absorber50
- Adjusting the Rebound Damping of the Shock Absorber51
- Measuring the Rear Wheel Dimension Unloaded52
- Checking the Static Sag of the Shock Absorber53
- Checking the Riding Sag of the Shock Absorber53
- Adjusting the Spring Preload of the Shock Absorber54
- Adjusting the Riding Sag55
- Checking the Basic Setting of the Fork55
- Adjusting the Compression Damping of the Fork56
- Adjusting the Rebound Damping of the Fork56
- Handlebar Position57
- Adjusting the Handlebar Position58
13 Service Work on the Chassis 1359
- Raising the Motorcycle with a Lift Stand59
- Removing the Motorcycle from the Lift Stand59
- Bleeding the Fork Legs60
- Removing the Fork Protector60
- Installing the Fork Protector61
- Cleaning the Dust Boots of the Fork Legs61
- Removing the Fork Legs62
- Installing the Fork Legs63
- Removing the Lower Triple Clamp63
- Installing the Lower Triple Clamp64
- Checking Steering Head Bearing Play66
- Adjusting Steering Head Bearing Play67
- Greasing the Steering Head Bearing68
- Removing Front Fender68
- Installing Front Fender69
- Removing the Shock Absorber70
- Installing the Shock Absorber70
- Folding the Seat up71
- Locking the Seat71
- Removing the Spoiler71
- Installing the Spoiler72
- Mounting the Protection Cap73
- Removing the Protection Cap73
- Checking the Battery Discharge Plug Form Ring73
- Checking for Chain Dirt Accumulation74
- Cleaning the Chain74
- Checking the Chain Tension75
- Adjusting the Chain Tension76
- Checking the Chain, Rear Sprocket, Engine Sprocket, and Chain Guide77
- Checking the Frame79
- Checking the Link Fork79
- Checking the Rubber Grip80
14 Brake System 1481
- Checking the Free Travel of the Front Brake Lever81
- Adjusting the Free Travel of the Front Brake Lever81
- Checking the Brake Discs81
- Checking the Front Brake Fluid Level82
- Adding Front Brake Fluid83
- Checking the Front Brake Linings84
- Changing the Brake Linings of the Front Brake85
- Checking the Free Travel of the Rear Brake Lever87
- Adjusting the Free Travel of the Rear Brake Lever88
- Checking the Rear Brake Fluid Level88
- Adding Rear Brake Fluid88
  - Checking the Rear Brake Linings90
  - Changing the Rear Brake Linings90
15 Wheels, Tires 1593
- Removing the Front Wheel93
- Installing the Front Wheel93
- Removing the Rear Wheel94
- Installing the Rear Wheel95
- Checking the Tire Condition97
- Checking Tire Pressure97
- Checking the Spoke Tension98
16 Electrical System100
- Removing the 12-V Battery100
- Installing the 12-V Battery100
- Charging the 12-V Battery101
- Changing the Fuses of Individual Electrical Power Consumers102
- Removing the Headlight Mask with the Headlight104
- Installing the Headlight Mask with the Headlight104
- Changing the Headlight Bulb105
- Changing the Turn Signal Bulb106
- Checking the Headlight Setting107
- Adjusting the Headlight Range107
- Changing the Combination Instrument Battery108
- Diagnostic Connection109
17 Powerpack Hv, Battery Charger110
- Removing the Powerpack HV110
- Installing the Powerpack HV111
- Overview of the Battery Charger for the Powerpack HV (Option: Battery Charger 1)112
- Overview of the Battery Charger for the Powerpack HV (Option: Battery Charger 2)113
- Positioning the Battery Charger113
- Checking Residual Current Protection Switch (Option: Battery Charger 1)115
- Charging the Powerpack HV115
- Charging the Powerpack HV in Charging Mode Storage119
- Changing Charging Socket Protection Cap122
18 Cooling System 18123
- Checking the Antifreeze and Coolant Level123
- Checking the Coolant Level124
- Draining the Coolant125
- Refilling with Coolant126
- Changing the Coolant127
19 Tuning the Engine 19129
- Selecting the Riding Mode129
20 Service Work on the Engine130
- Changing the Gear Oil130
21 Cleaning, Care132
- Cleaning the Motorcycle132
- Checks and Maintenance Steps for Winter Operation133
22 Storage134
- Preparing for Use after Storage135
23 Troubleshooting136
- Vehicle Troubleshooting136
- Troubleshooting of the Battery Charger138
- Troubleshooting Powerpack HV on the Battery Charger139
24 Technical Data140
- Engine140
- Engine Tightening Torques140
- Capacities140
- Gear Oil140
- Coolant140
- Chassis140
- Electrical System141
- Tires142
- Fork142
- Shock Absorber142
- Chassis Tightening Torques143
25 Substances 25145
26 Auxiliary Substances 26147
27 Standards148
28 Index of Special Terms 28149
29 List of Abbreviations150
30 List of Symbols 30151
- Yellow and Orange Symbols151
- Green and Blue Symbols151
- Index154

Brand	KTM
Model	Freeride E-XC 2021
Category	Motorcycle
Language	English

KTM Freeride E-XC 2021 User Manual

Table of Contents

Questions and Answers:

KTM Freeride E-XC 2021 Specifications

Related product manuals