Fuel System
Only use the grades of fuel recommended in the fuel
specification, refer to Technical Data, page 139.
Always observe the greatest cleanliness during
refueling and work on the fuel system.
All work on the unit injectors of the engine must be
carried out by an authorized Volvo Penta workshop.
WARNING!
Fire hazard.
A fuel spill onto a hot surface or electrical components
can cause fire.
When carrying out work on the fuel system, make sure
the engine is cold.
WARNING!
Store fuel soaked rags and other flammable material
so that there is no danger of them catching fire. Fuel
soaked rags can ignite spontaneously under certain
conditions.
Maintenance
98 47708638 09-2016 © AB VOLVO PENTA
Oil Filter/By-pass Filter, Change
The oil filter and bypass filter must be replaced at every
oil change.
Remember to hand the old filters in to a re-cycling
station.
WARNING!
Hot oil and hot surfaces can cause burns.
1 Place a collection vessel underneath the filter drip
tray to avoid oil spillage.
2 Clean the filter bracket.
3 Unscrew the bypass filter (1) and the oil filters (2)
with a suitable puller.
4 Check that the mating surfaces on the filter bracket
are clean and that no remains from the old gaskets
are left.
5 Moisten the gaskets on the new filters with engine
oil.
6 Screw on the filter by hand until the rubber gasket
touches the filter bracket mating surface. Then turn
a further 3/4 to 1 turn.
7 Start the engine, run at low idle, and check that no
leakage occurs. Check the oil level after the engine
has stopped.
2
1
2
P0010347
To Next Page
Loading...
Need help?
General
