Polaris 2009 Sportsman XP 850 User Manual

3.2
ELECTRONIC FUEL INJECTION
SPECIAL TOOLS
Part Numbers / Descriptions
IMPORTANT: For the most recent information on
Digital Wrench™ software and fileset downloads
please visit the website: www.polaris.diagsys.com
Fuel Pressure Gauge Kit - PU-43506-A
IMPORTANT: The EFI fuel system remains under high
pressure, even when the engine is not running.
Before attempting to service any part of the fuel
system, the pressure must be relieved. The Fuel
Pressure Gauge Kit has an integrated pressure relief
valve that can be used to bleed off pressure.
Fuel Pressure Gauge Adaptor - PS-48762
Used in conjunction with PU-43506-A to check fuel pressure.
Throttle Position Sensor Tester Kit - 2201519
This tester allows the use of a digital multi-meter to test TPS
function and perform the “TPS Adjustment” procedure. Polaris
Dealers can order special tools from SPX Corporation.
PART
NUMBER
TOOL DESCRIPTION
PU-43506-A Fuel Pressure Gauge Kit
PS-48762 Fuel Pressure Gauge Adaptor
2201519 Throttle Position Sensor Tester Kit
PU-47063
Digital Wrench™ Diagnostic Software
(Includes most recent version of software
and a serial number)
PU-47471
Digital Wrench™ SmartLink Module Kit
(PU-47470, PU-47469, PU-47468)
PU-47470
Digital Wrench™
PC Interface Cable
PU-47469
Digital Wrench™
Vehicle Interface Cable
PU-47468
Digital Wrench™
SmartLink Module
WARNING
* Gasoline is extremely flammable and explosive
under certain conditions.
* EFI components are under high pressure. Verify
system pressure has been relieved before
disassembly.
* Never drain the fuel system when the engine is hot.
Severe burns may result .
* Do not overfill the tank. The tank is at full capacity
when the fuel reaches the bottom of the filler neck.
Leave room for expansion of fuel.
* Never start the engine or let it run in an enclosed
area. Gasoline powered engine exhaust fumes are
poisonous and can cause loss of consciousness and
death in a short time.
* Do not smoke or allow open flames or sparks in or
near the area where refueling is performed or where
g a so l i ne i s st o r ed .
* If you get gasoline in your eyes or if you should
swallow gasoline, seek medical attention immediately.
* If you spill gasoline on your skin or clothing,
immediately wash with soap and water and change
c l o t h i n g .
* Always stop the engine and refuel outdoors or in a
well ventilated area.
Relief Valve
Adaptor shown is
included with kit.
7/16-20 Schrader
PartShark.com
877-999-5686

Polaris 2009 Sportsman XP 850 Specifications

General

Brand	Polaris
Model	2009 Sportsman XP 850
Category	Offroad Vehicle
Language	English