10.54
9924864 - 2012-2014 SPORTSMAN 800 / 6X6
© Copyright 2013 Polaris Sales Inc.
3. If the voltage is below 12.8 V, the battery will need to
be recharged.
TO SERVICE A LOW MAINTENANCE BATTERY
FOLLOW SETS 4–6
4. Remove battery from the vehicle.
5. Test battery with a voltage meter or load tester to
determine battery condition. This will determine the
length of time required to charge the battery to full
capacity. Refer to capacity table.
6. Charge battery using a variable rate charger.
Low Maintenance Battery Charging
If battery voltage is 12.8 V or less, the battery may need
recharging. When using an automatic charger, refer to
the charger manufacturer's instructions for recharging.
When using a constant current charger, use the following
guidelines for recharging.
NOTE: Always verify battery condition before and 1-
2 hours after the end of charging.
WARNING
An overheated battery could explode, causing severe
injury or death. Always watch charging times carefully.
Stop charging if the battery becomes very warm to the
touch. Allow it to cool before resuming charging.
BATTERY CHARGING REFERENCE TABLE
STATE OF
CHARGE
VOLTAGE ACTION
CHARGE
TIME
100% 12.8-13 V
None, check
voltage at 3
mos. after
manufacture
date
None
Required
75-100%
12.5-12.8
V
May need slight
charge
3-6 Hours
50-75%
12.0-12.5
V
Needs Charge
5-11 Hours
25-50%
11.5-12.0
V
Needs Charge
At least 13
hours,
verify state
of charge
0-25%
11.5 V
or less
Needs Charge
At least 20
hours
ELECTRICAL
To Next Page
Loading...
Need help?
General
