Home
AGCO
Tractor
FENDT 1038 Vario S4
AGCO FENDT 1038 Vario S4 User Manual
5
of 1
of 1 rating
284 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
2.10.6.2 Drain leak oil from front hydraulic couplings
Procedure
1.
Place a suitable collection container
underneath the leak oil tank.
2.
Pull out the plug (arrow) from the leak oil
tank and allow the oil to drain.
3.
When the oil has completely drained, push
the plug (arrow) back in.
Fig. 62
2. Service and maintenance
Maintenance
53
530.020.020.011 Rev.A
50
52
Table of Contents
Maintenance
5
Table of Contents
5
1. Safety Instructions
9
Safety Instructions
9
Introduction
11
Safety Advice in the Instructions and on the Vehicle
11
Environmental Protection
12
Information Regarding Toxic Substances and Pollutants
12
Substances that Are Harmful to Health
12
Safety - Symbols and Terms Used
13
General Maintenance Instructions
14
Special Safety Instructions for Tractor Maintenance
14
Obligatory Steps to be Taken before Leaving the Tractor
15
Special Instructions for Cleaning the Tractor
15
2. Service and Maintenance
17
Service and Maintenance
17
General
19
Engine Cover and Side Panels
20
Open and Close the Engine Cover
20
Side Panels
21
Check the Engine Oil Level
22
Drain the Engine Oil
22
Engine
22
General
22
Change the Engine Oil Filter
23
Fill with Engine Oil
24
Change the Fuel Filter
25
Fuel System
25
Fuel Pre-Filter
26
Drain Water and Dirt
27
Filter Change
27
Message in Multiple Display
27
Bleeding Air from the Fuel System
28
Change the Adblue® Filter
28
Change Breather Filter on the Adblue® Tank
29
Air Filter Contamination Display in the Terminal
30
Intake System
30
Remove and Install the Main Cartridge
31
Change the Safety Cartridge
32
Install the Main Cartridge
32
Remove Main Cartridge
32
Check the Coolant Level
34
Clean the Cooling System
34
Cooling System
34
Re-Fill with Coolant
36
Drain Coolant
37
Re-Fill with Coolant
37
Clean the Cooling/Heating System Internally
38
Check V-Belt
39
V-Belt
39
Bleed the Suction Line of the Hydrostatic Fan Drive
40
Change the the Front Axle Differential Oil
40
Front Axle
40
Apply Pressure to the Front Axle Housing
41
Bleed the Suction Line
41
Change the Front Axle Suction and Return Filter
41
Change the Oil in the Front Axle Final Drive Hubs
42
Drain the Oil
42
Filling with Oil
42
Check the Oil Level in the Transmission
43
Drain Transmission Oil
43
Transmission and Axle Drives
43
Drain Final Drive Oil
44
Fill the Final Drives with Oil
44
Pour in the Transmission Oil
44
Change the Pressure and Suction Filters
45
Replacing the Suction Filter
45
Check Hydraulics Oil Level
46
Drain Hydraulic Oil
46
Hydraulic System
46
Change Hydraulic System Filter
47
Fill with Hydraulic Oil
47
Filling with Oil
47
Clean the Flat-Face Self-Sealing Hydraulic Couplings
48
Drain Leaked Oil from Rear Hydraulic Couplings
50
Leak Oil from Hydraulic Couplings
50
Drain Leak Oil from Front Hydraulic Couplings
51
Check the Toe-In
52
Steering
52
Steering and Front Wheels
52
Fresh Air Filter
53
General
53
Heating and Ventilation
53
Recirculation Filter
53
Compressed Air System
55
Compressed Air System Function Test
55
Draining Condensation Water from the Air Receiver
55
Replace the Air Dryer Cartridge
55
Air-Conditioning System
57
Condenser
57
Fill Windscreen Washer
58
Windscreen Washer
58
Towing Equipment
59
Towing Equipment Wear Limits
59
Trailer Hitch Maintenance
59
Power Lift
61
Three-Point Linkage Wear Limits
61
Cleaning
62
Cleaning the Tractor
62
Clean with the High-Pressure Cleaner
63
Cleaning the Varioterminal
63
Clean the Cab's Air Spring Bellows
64
Batteries
65
Electric Welding
65
Electrical and Electronic Systems
65
General
65
Adjust the Auxiliary Lighting
66
Adjust the Front Headlamps
66
Additional Installation of Electrical and Electronic Equipment
67
Fuse Assignment
68
Fuses
68
3. Faults and Remedy
77
General
79
Warning and Fault Messages
79
Warning Messages
79
Fault Messages
90
Clear a Warning or Fault Message
113
General Faults
113
General
122
Information and Fault Messages Variotronic Ti and Implement Control
122
Fault Code Tables
123
Fault Code 00.0.00
124
Fault Code 01.1.00
128
Fault Code 02.0.00
135
Fault Code 03.1.00
137
Fault Code 04.1.00
139
Fault Code 05.1.00
152
Fault Code 06.1.00
157
Fault Code 08.1.00
163
Fault Code 09.1.00
168
Fault Code 0A.1.00
173
Fault Code 0B.1.00
184
Fault Code 0D.1.00
188
Fault Code 0E.1.00
191
Fault Code 0F.1.00
196
Fault Code 10.1.00
201
Fault Code 12.1.00
203
Fault Code 15.1.00
210
Fault Code 17.1.00
212
Fault Code 18.1.00
213
Fault Code 1D.1.00
217
Fault Code 1F.1.00
225
Fault Code 20.1.00
226
Emergency Mode
231
General
231
Transmission Control Unit Faulty
231
Transmission Engaged
231
Access to Mechanical Emergency Operation
233
Mechanical Selection of Transmission Ratio
233
Mechanical Neutral Position Using Auxiliary Lever
234
Towing Instructions
234
Towing
235
4. Technical Data
237
Technical Data
239
Technical Data: General
239
Technical Data: Gearbox
240
Technical Data: Diesel Engine
242
Technical Data: Air Conditioning System - Cab - Hydraulic System
244
Technical Data: Front Axle
244
Technical Data: Compressed Air System, Electrics & Front Power Lift
245
Tire Pressures
247
Tires
247
Change Wheels
248
Tire Combinations
252
Track Widths
253
Filling Quantities
254
Fuels and Lubricants
254
Operating Fluids, General
254
Filling Points
256
Biodiesel
258
Adblue
259
Biodegradable Hydraulic Oil
259
Vehicle Registration on AGCO Net
262
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the AGCO FENDT 1038 Vario S4 and is the answer not in the manual?
Ask a question
AGCO FENDT 1038 Vario S4 Specifications
General
Brand
AGCO
Model
FENDT 1038 Vario S4
Category
Tractor
Language
English
Related product manuals
AGCO FENDT 1046 Vario S4
284 pages
AGCO FENDT 1050 Vario S4
284 pages
AGCO FENDT 714 Vario S4
51 pages
AGCO FENDT 718 Vario S4
51 pages
AGCO FENDT 720 Vario S4
51 pages
AGCO FENDT 722 Vario S4
51 pages
AGCO FENDT 724 Vario S4
51 pages
AGCO FENDT 700 Vario S4 Series
51 pages
AGCO FENDT 1000 Vario
284 pages
AGCO FENDT 824 Vario SCR
51 pages
AGCO FENDT 822 Vario SCR
51 pages
AGCO FENDT 828 Vario SCR
51 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General