Honda BF8D User Manual

78
Troubleshooting Starting Problems
STARTING THE ENGINE
SYMPTOM POSSIBLE CAUSE
Engine switch OFF.
Shift lever not in NEUTRAL position.
Blown fuse.
Loose battery connector.
Out of fuel.
Vent knob not open.
Primer bulb not squeezed.
REMEDY
Emergency stop switch clip is not set.
Plug cap is not installed properly.
Engine flooded.
Turn engine switch key START.
Set shift lever in NEUTRAL position.
Replace fuse.
Connect battery cable securely.
Have your authorized Honda outboard motor
dealer charge battery.
Supply fuel.
Open vent knob.
Squeeze primer bulb to supply fuel.
Clean and dry spark plug.
Start using emergency starter rope.
Install plug cap securely.
Set emergency stop switch clip.
Weak battery.
Starter motor doesn’t turn over (Electric
starter type)
Starter motor turns but the engine
doesn’t start. (Electric starter type)
Pull the starter rope slowly until a
resistance is felt, then pull briskly.
(page 68 )
(page 61, 67 )
(page 46 )
(page 51 )
(page 57 )
(page 59 )
(page 71 )
(page 60, 66 )
(page 127 )
(page 117 )
(page 118 )
1.
2.
3.
4.
1.
2.
3.
4.
5.
6.
7.
1.
4.
5.
1.
2.
3.
6.
7.
2.
3.
4.
(Electric starter type)
11/09/05 18:08:29 32ZY0620_078

Honda BF8D Specifications

General

HP Rating	8 HP
Cooling System	Water cooled
Fuel Delivery	Carburetor
Ignition System	CDI
Starting System	Manual
Gear Ratio	2.33:1
Fuel Tank Capacity	12 L (external tank)
Engine Type	4-stroke
Full Throttle RPM Range	5, 000-6, 000 RPM
Shaft Length	381 mm (Short Shaft)