Maintenance chart
Correct maintenance is fundamental for ensuring the longevity of your vehicle and maintaining optimum
functionality and performance.
To this end, Aprilia offers a set of checks and maintenance services (at the owner's expense), that are
summarised in the table shown on the following page. Any minor faults must be reported without delay
to an Authorised Aprilia Dealer or Sub-Dealer without waiting until the next scheduled service to
solve it.
All scheduled services must be carried out at the specified intervals and mileage, as soon as the pre-
determined mileage is reached. Carrying out scheduled services on time is essential for the validity of
your warranty. For further information regarding Warranty procedures and ''Scheduled Maintenance'',
please refer to the ''Warranty Booklet''.
NOTE
CARRY OUT MAINTENANCE OPERATIONS AT HALF THE INTERVALS SPECIFIED IF THE VE-
HICLE IS USED IN PARTICULAR RAINY OR DUSTY CONDITIONS, OFF ROAD OR FOR TRACK
USE.
I: INSPECT AND CLEAN, ADJUST, LUBRICATE OR REPLACE IF NECESSARY
C: CLEAN, R: REPLACE, A: ADJUST, L: LUBRICATE
(1) Check at each engine start
(2) Check and clean and adjust or replace, if necessary, before every journey.
(3) Check and clean and adjust or replace, if necessary, every 1000 Km (621 mi)
(4) Replace every 2 years
(5) Replace every 4 years
(6) Every 5000 Km (3107 mi) if the vehicle is used for racing
(7) Every 10000 Km (6213 mi) if the vehicle is used for racing
ROUTINE MAINTENANCE TABLE
km x 1000
1 10 20 30 40
Rear shock absorber (6) I I
Set up (6) I I I I I
Cylinder equalisation I I I I
Spark plug (6) I R I R
Drive chain (3) I - L I - L I - L I - L I - L
Clutch cable L L L L L
Control cables and controls (6) I I I I I
Sprocket - pinion (6) I I I I
Rear suspension bearings - linkages I I
Steering bearings and steering clearance (6) I I I I
Wheel bearings (6) I I I I
Control unit diagnosis I I I I
Brake discs (6) I I I I I
Air filter (6) I R I R
Engine oil filter (6) R R R R R
Engine oil filter (on rose pipe) C
Fork I I
General vehicle operation (6) I I I I I
Valve clearance (7) A A
Cooling system (6) I I I I
Maintenance TUONO V4 R
MAIN - 60
To Next Page
Loading...
Need help?
General
