Yanmar EF-494T User Manual

1 PERIODICAL INSPECTION 1 PERIODICAL INSPECTION
EF494T TM 06/2011 edition
28
Line filter (Transmission oil element)
The line filter is of a cartridge type. Replace it with a
new one first 50 hours and then every 300 hours.
Replacing
(1) Remove the transmission oil and remove the
cartridge by turning anticlockwise.
(2) Apply a little oil on the rubber ring on the new
cartridge. Mount the cartridge by hand first
and tight it with filter wrench.
(3) After replacing the transmission oil, idle the
engine and check the oil level with dipstick. If
insufficient, add the oil.
(A) Line filter
NOTE:
Use genuine element. Otherwise, it
may cause trouble in the engine
Fuel filter element
Replace fuel filter every 300 hours.
Replacing
(1) Close fuel cock on water separator.
(2) Remove the cartridge by turning anticlockwise.
(3) Apply a little oil on the rubber ring on the new
cartridge. Mount the cartridge by hand first and
tight it with filter wrench.
(4) Open the cock and bleed the air from the fuel.
NOTE:
Use genuine element. Otherwise, FIE (Fuel
Injection Pump) will be in trouble, premature
wearing of plunger.
(A) Fuel filter
1.7 REPLACING COOLING WATER
DANGER
Never open the radiator cap when the radiator is
hot. You may be burned by the hot vapor.
Check
Open the bonnet and right side cover of the engine
and check if the sub tank water is within the upper
and lower limit marks. If insufficient, add water
through the supply port.
(A) Sub tank
(B) Supply port

Yanmar EF-494T Specifications

General

Brand	Yanmar
Model	EF-494T
Category	Tractor
Language	English