Polaris 2012 RANGER RZR 570 INTL User Manual

4.2
ELECTRONIC FUEL INJECTION
9923523 - 2012 RANGER RZR 570 Service Manual
© Copyright 2011 Polaris Sales Inc.
GENERAL INFORMATION
Special Tools
SPX Corporation: 1-800-328-6657or http://polaris.spx.com/.
Fuel Pressure Gauge Kit - PU-43506-A
IMPORTANT: The EFI fuel system remains under high
pres
sure, even when the engine is not running. Before
attempting to ser vice any part of the fuel system,
pressure mus t be reliev ed ( if ap plicable). The F uel
Pressure Gauge Kit has an integrated pressure relief
valve that can be used to bleed off pressure once you
have completed the fuel pressure test.
Fuel Pressure Gauge Adaptor - PV-48656
Digital Wrench™ Diagno
stic Software - PU-47063-A
This de aler-only sof tware inst alls on laptop co mputers
equ
ipped with a CD drive and serial port connection, and
is designed to re place multiple shop tools often used to
test EF I comp onents. It also includ es step-by-step
diagnostic pr ocedures to a id techn ician r epair an d
troubleshooting.
IMPORTANT: If the PC you are using is not equipped
with
a 9-pin serial port, a USB to serial port adaptor
will be necessary. A USB to serial port adaptor can be
purchased through DSA at:
www.diagsys.com
WARNING
* Gasoline is extremely flammable and explosive
under certain conditions.
* EFI components are under high pressure.
Verify system pressure has been
relieved before disassembly.
* Never drain the fuel system when the engine is hot.
Severe burns may result.
* Do not overfill the tank. The tank is at full capacity
when the fuel reaches the bottom of the filler neck.
Leave room for expansion of fuel.
* Never start the engine or let it run in an enclosed area.
Gasoline powered engine exhaust fumes are
poisonous and can cause loss of consciousness
and death in a short time.
* Do not smoke or allow open flames or sparks in or near
the area where refueling is performed or where
g a s o li ne i s s to r e d .
* If you get gasoline in your eyes or if you should
swallow gasoline, seek medical attention immediately.
* If you spill gasoline on your skin or clothing,
immediately wash with soap and water
and change clothing.
* Always stop the engine and refuel outdoors
or in a well ventilated area.
PART
NUMBER
TOOL DESCRIPTION
PU-43506-A Fuel Pressure Gauge Kit
PV-48656 Fuel Pressure Gauge Adaptor
PU-47063-B
Digital Wrench
™ Diagnostic Software
(Includes most recent version of software
w/serial number, standard interface cable
and SmartLink Module Kit)
PU-47471
Digital Wrench
™ SmartLink Module Kit
(PU-47470, PU-47469, PU-47468)
PU-47470
Digital Wrench
™
PC Interface Cable
PU-47469
Digital Wrench
™
Vehicle Interface Cable
PU-47468
Digital Wrench
™
SmartLink Module
Relief Valve
Adaptor shown is
included with kit.
Adaptor works with
PU-43506-A
Disconnect here and connect
in-line w/fuel pump outlet

Polaris 2012 RANGER RZR 570 INTL Specifications

General

Brand	Polaris
Model	2012 RANGER RZR 570 INTL
Category	Offroad Vehicle
Language	English