2.30
MAINTENANCE
9923523 - RANGER RZR 570 Service Manual
© Copyright 2011 Polaris Sales Inc.
Tire Pressure
Drive Shaft Boot Inspection
Inspect the drive shaft boots for damage, tears, wear or
leaking grease. If the boots exhibit any of these symptoms,
they should be replaced. Refer to Chapter 7 for drive shaft
boot replacement.
ELECTRICAL AND IGNITION SYSTEM
Battery Maintenance
Keep battery terminals and connections free of corrosion.
If cleaning is necessary, remove the corrosion with a stiff
wire brush. Wash with a solution of one tablespoon baking
soda and one cup water. Rinse well with tap water and dry
off with c lean shop towels . Coat the terminals with
dielectric grease or petroleum jelly.
NOTE: Batteries must be fully charged before use or
bat
tery life will b e re duced by 10 -30% of fu ll
potential. Ch arge battery acc ording t o “Charging
Procedure” provided in Cha pter 1 0. Do not u se the
vehicle’s stator/alternator to charge a new battery.
Maintain proper tire pressure.
Refer to the warning tire pressure decal
applied to the vehicle.
Tire Pressure Inspection (Cold)
Front Rear
10 psi (55 kPa) 12 psi (55 kPa)
CALIFORNIA PROPOSITION 65 WARNING:
Batteries, battery posts, terminals and related
accessories contain lead and lead compounds,
and other chemicals known to the State of
California to cause cancer and birth defects or
other reproductive harm.
WASH HANDS AFTER HANDLING.
Battery electrolyte is poisonous. It contains
sulfuric acid. Serious burns can result from
contact with skin, eyes or clothing. Antidote:
External: Flush with water.
Internal:
Drink large quantities of water or milk.
Follow with milk of magnesia, beaten egg, or
vegetable oil. Call physician immediately.
Eyes: Flus
h with water for 15 minutes and get
prompt medical attention.
Batteries produce explosive gases.
Keep sparks
, flame, cigarettes, etc. away.
Ventilate when charging or using in an enclosed
space. Always shield eyes when
working near batteries.
KEEP OUT OF REACH OF CHILDREN.
To Next Page
Loading...
Need help?
General
