Belarus 3522.5 User Manual

3522.5-0000010 OM
330
8. Tractor storage
8.1 General instruction
ATTENTION: THE PRESENT SECTION CONTAINS THE STORAGE REGULA-
TIONS FOR TRACTOR “BELARUS-3522.5” CHASSIS SYSTEMS AND UNITS. ENGINE
STORAGE, PRESERVATION, REPRESERVATION, DEPRESERVATION REGULATIONS
ARE SPECIFIED IN THE ENGINE OPERATION MANUAL!
The tractors shall be stored according to the requirements of GOST 7751-85 in the
indoor area or under a shed.
If indoors premises are not available, tractors may be stored on outdoor special
sites, with obligatory preservation, sealing and components dismounting, that require
warehousing.
Put tractors in the inter-shift storage, if their operation is interrupted for up to 10
days, short-term storage if duration of idle interval is from ten days to two months, and
long-term storage if interruption of use lasts for over two months. Start preparation for
short-term storage straight after works completion, and for long-term storage – not later
than ten days after works termination.
It is forbidden to store a nonworking tractor on tires for more than 10 days. In case if
out-of-service time exceeds 10 days the tractors shall be put on the supporting block, pres-
sure in tire should be reduce down to 70%...80% of the rated value. To protect the tires from
the insolation and atmospheric precipitation they must be covered with whitish covers made
of dense texture or with special protective substance (limewashing, metal and casein mix-
ture and the like). To protect spools from the clogging and damage, the tire valves shall be
covered with metal or rubber caps.
8.2 Requirements for inter-shift storage of machines
Tractor may be stored on storage yards, and inter-shift storage grounds, or directly
on works execution sites. All openings, through which atmospheric precipitation can get
inside tractor cavities, shall be tightly covered. Accumulator batteries shall be switched off.
8.3 Requirements for short-term tractors storage
Put tractor in storage in complete set without dismounting parts and assembly units.
Tires storage is regulated by provisions of subsection 8.1 “General instructions”.
Disconnect the accumulator batteries. Electrolyte level and density should comply
with recommendations for storage and maintenance of accumulator batteries, listed in
clause 6.4.3.2 of subsection 6.4.3 “Maintenance services in every 250 hours of operation”
If tractor is stored at low temperatures or over one month, accumulator batteries must be
dismounted and sent to warehouse.
8.4 Requirements for outdoors long-term storage
Before putting a tractor in the storage check its technical condition. Carry out basic
maintenance services.
Technological maintenance when preparing tractor for long-term storage includes:
- cleaning and washing;
- dismounting and preparing for storage tractor components subject to storage in
specially equipped warehouses;
- sealing of openings and cavities from ingress of moisture and dust;
- tractor and its components’ preservation;
- putting tractor on supporting blocks (plates)).
https://tractormanualz.com/

Belarus 3522.5 Specifications

General

Brand	Belarus
Model	3522.5
Category	Tractor
Language	English