LUBRICATION
AND MAINTENANCE---
-----
LUBRICATION AND MAINTENANCE CHART
The
numbers
in
the
second
column
refer
to
the
Operation
nwnber
or
Figure
number
contained
in
the
fol-
lowing pages
of
this section.
-;
~!
•1
.!!
Hours
Operation
I
Operated
No.
Service Requirements
~
~~
i
4 Engine oil level
x x
Every
5 Engine coolant recovery system
x x
10hours
6
Radiator and oil cooler x
or
Dally 7 Power steering oil level
x x
8 Pre-cleaner x
9
Oil
bath
air cleaner (where· fitted)
x
x
x
When
warning
10 Dry air cleaner (where fitted) x
light glows
11
Oil
bath air cleaner (where fitted) x
x
12
Front
and rear wheel nuts
x x
13
Tires
x x
14 Clutch
pedal
free play x
x
Every
15 Fuel filter/sediment separator
x
SO
hours
16
Rear axle oil level
x
x
17
Belt
pulley oil level (where
fittOO.)
x x
18
Front axle differential oil level (four wheel drive only) x
x
19
Front
axle
hub oil levels (four
wheel
drive only)
x x
20/29
All
grease fittings
x
• 30/31
Engine oil and filter
x
32/33
Transmission oil level x x
34/35
Hydraulic oil filter(s)
x
Every
36
Footbrakes x x
300hours 37/38
Handbrake x
x
39 Safety frame bolts x x
40
Fan
belt tension x
x
41 Dry air cleaner (where fitted)
42
Oil
bath
air
cleaner (where
fittOO.)
x x
43 Dry air cleaner (where fitted)
x
Every
44
Front
wheel bearings (two wheel drive)
x
x
x
x
600
boors
#45
Starter motor pinion
x x x
46/47
Valve tappet clearance
x x
48/49
Fuel filter/sediment separator
x x
50/51
Fuel injectors
x x x
52/53
Bleeding the fuel system
Every
1200
55/57
Rear axle oil x
boun or
58/61
Transmission oil
and
internal filter x
annually
62/63
Front axle oil (four wheel drive)
x
64
Front
axle
hub
oil (four wheel drive)
x
65
Belt
pulley oil (where fitted)
x
66/67
Power
steering
oil
and filter x
68
Dry air cleaner (where fitted)
x
Every
1200
hours
or
69(11
Coolant inhibitor/filtration system
x
x
Two years
As
Required
72/86
General maintenance
* Oil
change
interval will
be
reduced
if
the diesel fuel
has
a
high
sulfur content or
if
the
tractor
is
operated
in
exaremely
cold temperalUres.
See
page
13
of
this
section.
# Frequency
depends
on
clutch
usage.
2
'
x
To Next Page
Loading...
Need help?
General
