2-2 PERIODIC MAINTENANCE
PERIODIC MAINTENANCE SCHEDULE
The chart below lists the recommended intervals for all the required periodic service work necessary to keep
the motorcycle operating at peak performance and economy. Maintenance intervals are expressed in terms of
kilometer, miles and months, and are dependant on whichever comes first.
IMPORTANT (USA only):
The periodic maintenance intervals and service requirements have been established in accordance with EPA
regulations. Following these instructions will ensure that the motorcycle will not exceed emission standards
and it will also ensure the reliability and performance of the motorcycle. The chart below lists the recom-
mended intervals for all the required periodic service work necessary to keep the motorcycle operating at peak
performance and economy. Mileages are expressed in terms of kilometer, miles and time for your conve-
nience.
NOTES:
More frequent servicing may be performed on motorcycles that are used under severe conditions.
PERIODIC MAINTENANCE CHART
Interval km 1 000 6 000 12 000 18 000 24 000
miles 600 4 000 7 500 11 000 15 000
Item months 1 6 12 18 24
Air cleaner element - I I R I
Spark plugs - I R I R
Valve clearance - - - - I
Engine oil R RRRR
Engine oil filter R - - R -
Fuel line - I I I I
Replace fuel hose every 4 years.
Idle speed I I I I I
Throttle valve synchronization
I
-I-I
(E-33 only)
Evaporative emission control system - - I - I
(E-33 only) Replace vapor hose every 4 years.
PAIR (air supply) system - - I - I
Throttle cable play I I I I I
Clutch - I I I I
Radiator hoses - I I I I
Engine coolant Replace every 2 years.
Drive chain I I I I I
Clean and lubricate every 1 000 km (600 miles).
Brakes IIIII
Brake hoses - I I I I
Replace every 4 years.
Brake fluid - I I I I
Replace every 2 years.
Tires - I I I I
Steering I - I - I
Front forks - - I - I
Rear suspension - - I - I
Exhaust pipe bolts and muffler bolt and nut T - T - T
Chassis bolts and nuts T T T T T
I = Inspect and adjust, clean, lubricate or replace as necessary.
R = Replace
T = Tighten
To Next Page
Loading...
Need help?
General
