1-7
GENERAL
INFORMATION
PRECAUTION
AND
GENERAL
INSTRUCTION
Observe the following items
without
fail when servicing, disassembling
and
reassembling motorcycles.
o Do
not
run engine indoors
with
little
or
no ventilation.
o
Be
sure
to
replace packings,
gaskets,
circlips, a-rings and cotter pins
with
new
ones.
CAUTION:
Never
reuse
a circlip.
After
a circlip
has
been
removed
from
a shaft,
it
should
be
discarded and a new
circlip must
be
installed.
When
installing a new circlip,
care
must
be
taken
not
to
expand the end
gap
larger than required
to
slip
the circlip over the shaft.
After
installing a circlip, always insure
that
it
is
completely
seated
in its groove and securely fitted.
o Tighten cylinder
head
and
case
bolts and nuts beginning
with
larger diameter and ending
with
smaller
diameter, and from inside
to
outside diagonally,
to
the specified tightening torque.
o
Use
special tools where specified.
o
Use
genuine parts and recommended oils.
o
When
2
or
more persons
work
together, pay attention
to
the safety
of
each
other.
o
After
the reassembly, check parts
for
tightness
and
operation.
o Treat gasoline, which
is
extremely flammable and highly explosive,
with
greatest care. Never
use
gasoline
as
cleaning solvent.
Warning, Caution
and
Note
are
included in this manual occasionally, describing the following contents.
WARNING
.......•....
The personal safety
of
the rider
or
bystanders maybe involved. Disregarding
this information could result in personal injury.
CAUTION
. . . . . . . . . . .
..
These
instructions
point
out
special service procedures
or
precautions
that
must
be
followed
to
avoid damaging the machine.
NOTE . . . . . . . . . . . . . .
..
This provides special information to make maintenance easier or important
instructions clearer.
REPLACEMENT
PARTS
When
you replace any parts,
use
only
genuine SUZUKI replace-
ment parts,
or
their equivalent. Genuine SUZUKI parts
are
high
quality
parts which
are
designed
and
built
specifically
for
SUZUKI
vehicles.
CAUTION:
Use
of
replacement parts which
are
not
equivalent in
quality
to
genuine SUZUKI parts
can
lead
to
performance problems
and
damage.
To Next Page
Loading...
Need help?
General
