6 — Routine Maintenance
134
Operator Manual
AMSCO® 7000 Series 10432589_G
Table 6-1. Routine Maintenance - Check List (continued)
Usage and utility conditions may require more or less frequent inspections. Subsystem
5.4
Verify washer/disinfector has proper labels (caution, warning, etc.).
Cabinet
6.0 2X PER YEAR
6.1
Verify operation of Emergency Stop pushbuttons (one on each side of
washer/disinfector; see Section 6.16, Verifying Emergency Stop Pushbuttons ).
Emergency
Features
6.2
Perform sump safety level test (reminder is displayed every 979 cycles; see Section 6.14,
Sump Safety Level Test).
Chamber
7.0
AS REQUIRED
7.1
Change printer paper roll (see Section 6.9, Changing Printer Paper Roll and Printer Ink
Cartridge (Accessory)).
Printer
7.2
Change chemical container (see Section 6.8, Replacing Chemical Container).
Chemical
System
7.3
ATLAS WAV System (if present): Refer to ATLAS WAV System Operator Manual
(10370540) for more detailed information about routine maintenance and refer to
ATLAS WAV System Maintenance Manual (P764337-328) for more detailed information
about preventive maintenance
Automation
7.4
SCS Conveyor System (if present): Refer to SCS Conveyor System Operator Manual
(P20506-634) for more detailed information about routine maintenance and refer to SCS
Conveyor System Maintenance Manual (P764332-715) for more detailed information
about preventive maintenance
Automation
7.5
The Customer must verify the quality of the air and water supplied to the
washer/disinfector at a determined frequency to prevent possible process issues and
the frequency must be determined by his utilities knowledge (ex.: dirty/hard water
might warrant more frequent tests). STERIS document General Notes Applicable to
Sterilizer and Washer Equipment Drawings (P062941091) provides the requirements.
Utilities
*Routine Maintenance is not covered under warranty.
6.3 Cleaning Debris Screen
WARNING
SLIPPING HAZARD
To prevent slips, keep floors dry. Promptly clean up any spills or drippage. For spills or
drippage of detergents or other chemicals, follow safety precautions and handling
procedures set forth on detergent or chemical label and/or Safety Data Sheet (SDS).
To Next Page
Loading...
Need help?
General
