Home
Suzuki
Offroad Vehicle
LT-A400
Suzuki LT-A400 Service Manual
4
of 1
of 1 rating
502 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Drive Chain / Drive T
rain / Drive Shaft:
3A-6
Rear Axle Component
s
B827H13106005
9
10
(a)
8
7
2
3
4
(a)
5
(b)
6
3
1
2
I827H131002
5-02
1.
Dust seal
6.
Rear axle housing (L
H)
:
55 N
â‹…
m (5.5 kgf-
m, 40 lb-ft)
2.
Snap ring
7.
Rear a
xle (RH)
:
60 N
â‹…
m (6.0 kgf-m, 43.5 lb-ft)
3.
Bearing
8.
Rear a
xle (LH)
:
Apply grease.
4.
Rear axle housing (RH)
9.
Final gear case cover
:
Do not reuse.
5.
O-ring
10.
T
railer towing
266
268
Table of Contents
Section 0 General Information
13
Default Chapter
13
Table of Contents
13
General Information
13
Component Location
26
Specifications
26
Scheduled Maintenance
30
Lubrication Points
31
Special Tool
34
0B-5 Maintenance and Lubrication
34
Spark Arrester Cleaning
36
Fuel Line Inspection
36
Engine Oil and Filter Replacement
36
Front Differential Gear Oil Inspection (LT-A400F, LT-F400F)
38
Front Differential Gear Oil Replacement (LT- A400F, LT-F400F)
39
Final Gear Oil Inspection
40
Final Gear Oil Replacement
40
Throttle Cable Play Inspection and Adjustment
42
Engine Idle Speed Adjustment
42
Drive V-Belt Inspection (LT-A400
42
Clutch Inspection (LT-F400
43
Drive Shaft Boots Inspection
43
F400F)
43
Front Brake System Inspection
44
Rear Brake Pedal / Rear Brake
45
Tire Inspection
46
Steering System Inspection
47
Toe-In Adjustment
47
Tightening Torque
48
Suspension Inspection
48
Chassis Bolt and Nut Inspection
48
Compression Pressure Check
50
Oil Pressure Check
50
Automatic Clutch Inspection (LT-A400
50
Specifications
51
Tightening Torque Specifications
51
Special Tools and Equipment
51
Recommended Service Material
51
Special Tool
51
Repair Instructions
53
Service Data
53
Specifications
53
Service Data (LT-A400
53
Service Data (LT-F400
53
Tightening Torque List (LT-A400
61
Tightening Torque List (LT-F400
63
Section 1 Engine
67
Precautions
70
Precautions for Engine
70
Engine General Information and Diagnosis
71
Diagnostic Information and Procedures
71
Engine Symptom Diagnosis
71
Precautions
73
Precautions for Emission Control Devices
73
Emission Control Devices
73
General Description
73
Carburetor System Description
73
Repair Instructions
74
Crankcase Breather (PCV) Hose Inspection
74
Crankcase Breather (PCV) Hose Removal and Installation
74
Schematic and Routing Diagram
75
Throttle Cable Routing Diagram
75
Engine Mechanical
75
Diagnostic Information and Procedures
76
Engine Mechanical Symptom Diagnosis
76
Compression Pressure Check
76
Repair Instructions
77
Engine Components Removable with the Engine in Place
77
Air Cleaner Element Removal and Installation
77
Air Cleaner Element Inspection and Cleaning
79
Air Cleaner Box Removal and Installation
79
Engine Assembly Removal
80
Engine Assembly Installation
83
Engine Top Side Disassembly
84
Engine Top Side Assembly
87
Cylinder Head Cover Disassembly and Assembly
94
Cylinder Head Cover Relate Parts Inspection
95
Cylinder Head Disassembly and Assembly
96
Cylinder Head Related Parts Inspection
97
Valve Guide Replacement
100
Valve Seat Repair
102
Camshaft Inspection
102
Cam Chain Tension Adjuster Inspection
104
Cam Chain Tensioner Inspection
104
Cam Chain Guide Inspection
104
Cylinder Inspection
104
Piston Ring Removal and Installation
105
Piston and Piston Ring Inspection
106
Engine Bottom Side Disassembly
108
Engine Bottom Side Assembly
117
Conrod and Crankshaft Inspection
132
Width between Crankshaft Webs
133
Crankshaft Oil Seal Inspection
133
Bearing Inspection
133
Bearing Removal and Installation
134
Specifications
141
Service Data (LT-A400/F, LT-F400
141
Special Tools and Equipment
143
Recommended Service Material
143
Special Tool
144
Engine Lubrication System
148
Precautions
148
Precautions for Engine Oil
148
Schematic and Routing Diagram
148
Engine Lubrication System Chart Diagram
148
Cylinder Head Cooling System Chart Diagram
150
Diagnostic Information and Procedures
151
Engine Lubrication Symptom Diagnosis
151
Oil Pressure Check
151
Repair Instructions
152
Engine Oil and Filter Replacement
152
Engine Oil Level Inspection
152
Oil Sump Filter Removal and Installation
152
Oil Sump Filter Inspection and Cleaning
153
Oil Jet Removal and Installation (LT-F400
153
Oil Jet Inspection (LT-F400
153
Oil Pump Drive Gear / Oil Pump Removal and Installation
153
Oil Pump Inspection
155
Oil Cooler and Oil Hose Components
156
Oil Cooler / Oil Cooler Hose Inspection and Cleaning
156
Oil Cooler / Oil Cooler Hose Removal and Installation
157
Oil Cooler Cleaning
158
Cooling Fan Components
159
Cooling Fan Inspection
159
Cooling Fan Removal and Installation
160
Cooling Fan Thermo-Switch Removal and Installation
160
Cooling Fan Thermo-Switch Inspection
161
Engine Oil Temperature Switch Removal and Installation
161
Engine Oil Temperature Switch Inspection
162
Oil Pressure Regulator Removal and Installation
162
Oil Pressure Regulator Inspection
163
Specifications
163
Tightening Torque Specifications
164
Special Tools and Equipment
164
Recommended Service Material
164
Special Tool
164
General Description
166
I.D. No. Location
166
Fuel System Description
167
Fuel System
166
Precautions
166
Precautions for Fuel System
166
Schematic and Routing Diagram
175
Carburetor Hose Routing Diagram
175
Diagnostic Information and Procedures
176
Carburetor Symptom Diagnosis
176
Repair Instructions
177
Fuel Tank Construction
177
Fuel Tank Removal and Installation
178
Fuel Valve Removal and Installation
178
Fuel Filter Inspection and Cleaning
179
Fuel Level Gauge Removal and Installation
179
Fuel Level Gauge Inspection
180
Throttle Cable Removal and Installation
180
Throttle Cable Inspection
180
Throttle Cable Play Inspection and Adjustment
180
Starter Cable Removal and Installation
180
Starter Cable Inspection
180
Starter Cable Play Inspection and Adjustment . 1G-15
180
Carburetor Components
181
Carburetor Assembly Removal and Installation
182
Carburetor Disassembly
182
Carburetor Assembly
185
Float Height Inspection and Adjustment
186
Carburetor Inspection and Cleaning
186
Engine Idle Speed Inspection
187
Fuel Line Inspection
187
Air Cleaner Element Removal and Installation . 1G-22
187
Air Cleaner Element Inspection and Cleaning . 1G-22
187
Specifications
187
Service Data (LT-A400/F, LT-F400
187
Tightening Torque Specifications
188
Special Tools and Equipment
188
Recommended Service Material
188
Special Tool
188
Ignition System
189
Schematic and Routing Diagram
189
Ignition System Diagram
189
Ignition System Components Location
189
Diagnostic Information and Procedures
189
Ignition System Symptom Diagnosis
189
No Spark or Poor Spark
190
Repair Instructions
191
Spark Plug Removal and Installation
191
Spark Plug Inspection and Cleaning
191
Ignition Coil and Plug Cap Inspection
191
Ignition Coil Removal and Installation
193
CKP Sensor Inspection
193
CKP Sensor Removal and Installation
194
Engine Stop Switch Inspection
194
Ignition Switch Inspection
194
Ignition Switch Removal and Installation
194
Specifications
195
Service Data (LT-A400/F, LT-F400
195
Tightening Torque Specifications
195
Special Tools and Equipment
195
Special Tool
195
Starting System
196
Schematic and Routing Diagram
196
Starting System Diagram
196
Component Location
196
Starting System Components Location
196
Diagnostic Information and Procedures
196
Starting System Symptom Diagnosis
196
Starter Motor will Not Run
197
Starter Motor Runs but Does Not Crank the Engine
197
Engine Does Not Turn Though the Starter Motor Runs
197
Repair Instructions
198
Starter Motor Components
198
Starter Motor Removal and Installation
198
Starter Motor Disassembly and Assembly
199
Starter Motor Inspection
199
Starter Relay Removal and Installation
200
Starter Relay Inspection
201
Neutral Relay Removal and Installation
201
Neutral Relay Inspection
202
Neutral Switch Diode Inspection
202
Ignition / Starter Control Relay Removal and Installation
203
Ignition / Starter Control Relay Inspection
203
Parking Brake Switch Inspection
203
Gear Position Switch Inspection
203
Starter Clutch Removal and Installation
204
Starter Driven Gear Bearing Removal and Installation
206
Starter Related Parts Inspection
206
Starter Button Inspection
207
Recoil Starter Components
207
Recoil Starter Assembly Removal and Installation
208
Recoil Starter Disassembly and Assembly
208
Recoil Starter Inspection
210
Special Tools and Equipment
211
Recommended Service Material
211
Special Tool
212
Specifications
211
Service Data (LT-A400/F, LT-F400
211
Tightening Torque Specifications
211
Schematic and Routing Diagram
213
Charging System Diagram
213
Charging System
213
Diagnostic Information and Procedures
213
Charging System Symptom Diagnosis
213
Battery Runs down Quickly
214
Component Location
213
Charging System Components Location
213
Repair Instructions
215
Battery Current Leakage Inspection
215
Regulated Voltage Inspection
215
Generator Inspection
216
Generator Removal and Installation
217
Regulator / Rectifier Inspection
222
Battery Components
223
Battery Charging
223
Battery Removal and Installation
225
Battery Visual Inspection
225
Specifications
226
Service Data (LT-A400/F, LT-F400
226
Tightening Torque Specifications
226
Special Tools and Equipment
226
Recommended Service Material
226
Special Tool
226
Exhaust System
228
Precautions
228
Precautions for Exhaust System
228
Repair Instructions
228
Exhaust System Components
228
Muffler / Exhaust Pipe Removal and Installation
229
Exhaust System Inspection
230
Spark Arrester Inspection
230
Specifications
231
Tightening Torque Specifications
231
Section 2 Suspension
233
Precautions
234
Precautions for Suspension
234
Diagnostic Information and Procedures
235
Suspension and Wheel Symptom Diagnosis
235
Suspension General Diagnosis
235
Repair Instructions
236
Front Suspension Components
236
Front Suspension Assembly Construction
237
Front Suspension Inspection
238
Front Shock Absorber Inspection
238
Front Shock Absorber Removal and Installation
238
Front Wheel Hub / Steering Knuckle Removal and Installation
238
Front Wheel Hub / Steering Knuckle Related Parts Inspection
241
Steering Knuckle Dust Seal / Front Wheel Hub Bearing Removal and Installation
241
Front Suspension Upper / Lower Arm Removal and Installation
243
Front Suspension Arm Related Parts Inspection
244
Steering Knuckle End Removal and Installation
245
Front Suspension Upper / Lower Arm Bushing Removal and Installation
246
Front Suspension
236
Special Tools and Equipment
247
Recommended Service Material
247
Special Tool
248
Specifications
247
Tightening Torque Specifications
247
Repair Instructions
249
Rear Suspension Components
249
Rear Shock Absorber Removal and Installation
250
Rear Suspension Inspection
250
Rear Shock Absorber Inspection
250
Swingarm Removal and Installation
250
Swingarm Inspection
251
Swingarm Bushing Removal and Installation
252
Rear Suspension
249
Special Tools and Equipment
252
Recommended Service Material
252
Specifications
252
Tightening Torque Specifications
252
Wheels and Tires
253
Precautions
253
Precautions for Wheel and Tire
253
Repair Instructions
254
Front and Rear Wheel Components
254
Front / Rear Wheel Removal and Installation
255
Tire Removal and Installation
255
Specifications
257
Service Data (LT-A400/F, LT-F400
257
Tightening Torque Specifications
257
Section 3 Driveline / Axle
259
Precautions
261
Precautions for Driveline / Axle
261
3A-1 Drive Chain / Drive Train / Drive Shaft
262
Diagnostic Information and Procedures
262
Drive Shaft Symptom Diagnosis
262
Repair Instructions
262
Front Drive Shaft Components (LT-A400F, LT-F400F)
262
Front Drive Shaft Assembly Removal and Installation (LT-A400F, LT-F400F)
263
Front Drive Shaft Disassembly and Assembly (LT-A400F, LT-F400F)
263
Front Drive Shaft Inspection (LT-A400F, LT- F400F)
266
Rear Axle Components
267
Rear Axle Construction
268
Rear Axle / Axle Housing Removal and Installation
268
Rear Axle / Axle Housing Inspection
270
Rear Axle Housing Disassembly and Assembly
271
Specifications
272
Tightening Torque Specifications
272
Special Tools and Equipment
272
Recommended Service Material
272
Special Tool
272
Differential
274
Diagnostic Information and Procedures
274
Drive Train Symptom Diagnosis
274
Repair Instructions
275
Front Drive (Differential) Components (LT-A400F, LT-F400F)
275
Front Drive (Differential) Construction (LT-A400F, LT-F400F)
276
Front Drive (Differential) Gear Oil Level Inspection (LT-A400F, LT-F400F)
277
Front Drive (Differential) Gear Oil Replacement (LT-A400F, LT-F400F)
277
Front Drive (Differential) Assembly Removal and Installation (LT-A400F, LT-F400F)
277
Front Drive (Differential) Assembly Disassembly and Assembly (LT-A400F, LT- F400F)
278
Front Drive (Differential) Related Parts Inspection (LT-A400F, LT-F400F)
286
Universal Joint Bearing / Pinion Gear Pilot Bearing Inspection
287
Front Drive (Differential) Gear Shim Inspection and Selection (LT-A400F, LT-F400F)
288
Final Gear Components
292
Final Gear Construction
293
Final Gear Oil Level Inspection
294
Final Gear Oil Replacement
294
Final Gear Assembly Removal and Installation
294
Final Gear Assembly Disassembly and Assembly
296
Final Gear Related Parts Inspection
301
Final Gear Backlash Inspection and Shim Adjustment
303
Transfer Cable Inspection and Adjustment (LT-A400F, LT-F400F)
306
Transfer Cable Removal and Installation (LT- A400F, LT-F400F)
306
Specifications
307
Tightening Torque Specifications
307
Special Tools and Equipment
308
Recommended Service Material
308
Special Tool
308
Diagnostic Information and Procedures
310
Transfer Symptom Diagnosis (LT-A400
310
Transfer Symptom Diagnosis (LT-F400
310
Transfer
310
Repair Instructions
311
Transfer Components (LT-A400
311
Transfer Components (LT-F400
312
Transfer Removal and Installation
313
Transfer Removal and Installation
316
Transfer Construction (LT-A400
317
Transfer Disassembly and Assembly (LT- A400
318
Transfer Idle Gear Bearing Removal and Installation (LT-F400
318
Inspection (LT-A400
322
Transfer Gearshift Cam Disassembly and
322
Transfer Gearshift Shaft No.1 Bearing
322
Transfer Related Parts Inspection
324
Gear Position (GP) Switch Inspection
325
Gear Position (GP) Switch Removal and Installation (LT-A400
325
Gear Position (GP) Switch Removal and Installation (LT-F400
326
Gearshift Linkage Inspection (LT-A400
328
Gearshift Shaft Oil Seal Removal and Installation (LT-A400
328
Transfer Range Lever Components
329
Transfer Range Lever Removal and Installation
329
Transfer Range Lever Disassembly and Assembly
330
Shift Rod Length Adjustment
330
Reverse Switch Inspection (LT-F400
330
Specifications
331
Service Data (LT-A400
331
Service Data (LT-F400
331
Tightening Torque Specifications
332
Special Tools and Equipment
332
Recommended Service Material
332
Special Tool
332
Propeller Shafts
333
Repair Instructions
333
Front Output Shaft Components
333
Output Shaft Removal and Installation
335
Rear Output Shaft Disassembly and Assembly (LT-A400
336
Rear Output Shaft Disassembly and Assembly (LT-F400
339
Front Output Shaft Disassembly and Assembly (LT-A400F, LT-F400F)
342
Rear Output Shaft Related Parts Inspection
343
Front Output Shaft Related Parts Inspection (LT-A400F, LT-F400F)
345
Drive Bevel Gear Removal and Installation (LT-A400
345
Drive Bevel Gear Removal and Installation (LT-F400
347
Driven and Drive Bevel Gear Shim Inspection and Adjustment
348
Driven and Drive Bevel Gear Shim Adjustment Information
352
Special Tools and Equipment
354
Recommended Service Material
354
Special Tool
354
Specifications
354
Service Data (LT-A400/F, LT-F400
354
Tightening Torque Specifications
354
Section 4 Brake
357
Precautions
359
Precautions for Brake System
359
Brake Fluid Information
359
Schematic and Routing Diagram
360
Front Brake Hose Routing Diagram
360
Brake Cable Routing Diagram
361
Brake Control System and Diagnosis
360
Repair Instructions
362
Brake Pedal Adjustment
362
Front Brake Light Switch Inspection
362
Rear Brake Light Switch Inspection
363
Rear Brake Light Switch Inspection and Adjustment
363
Parking / Rear Brake Light Switch Inspection
364
Parking Brake Switch Inspection
364
Brake Fluid Level Check
364
Front Brake Hose Inspection
364
Air Bleeding from Front Brake Fluid Circuit
364
Brake Fluid Replacement
365
Front Brake Hose Removal and Installation
366
Rear Brake Cable Removal and Installation
366
Front Brake Master Cylinder Components
367
Front Brake Master Cylinder Assembly Removal and Installation
367
Front Brake Master Cylinder / Brake Lever Disassembly and Assembly
369
Front Brake Master Cylinder Parts Inspection
370
Parking / Rear Brake Lever Removal and Installation
370
Rear Brake Pedal Construction
371
Rear Brake Pedal Removal and Installation
371
Diagnostic Information and Procedures
362
Brake Symptom Diagnosis
362
Specifications
372
Service Data (LT-A400/F, LT-F400
372
Tightening Torque Specifications
373
Special Tools and Equipment
373
Recommended Service Material
373
Special Tool
373
Front Brakes
374
Precautions
374
Precautions for Front Brakes
374
Front Brake Components
374
Front Brake Pad Inspection
375
Front Brake Pad Replacement
375
Front Brake Caliper Removal and Installation
376
Front Brake Caliper Disassembly and Assembly
377
Front Brake Caliper Parts Inspection
379
Front Brake Disc Removal and Installation
380
Front Brake Disc Inspection
381
Specifications
381
Service Data (LT-A400/F, LT-F400
381
Tightening Torque Specifications
382
Special Tools and Equipment
382
Recommended Service Material
382
Special Tool
382
Rear Brakes
383
Schematic and Routing Diagram
383
Rear Brake Breather Hose Routing Diagram
383
Precautions
383
Precautions for Rear Brake
383
Repair Instructions
384
Rear Brake Components
384
Rear Brake Construction
385
Rear Brake Shoe Inspection
385
Rear Brake Disassembly and Assembly
385
Rear Brake Related Parts Inspection
390
Specifications
391
Service Data (LT-A400/F, LT-F400
391
Tightening Torque Specifications
391
Special Tools and Equipment
392
Recommended Service Material
392
Parking / Rear Brake Lever Inspection and Adjustment
393
Schematic and Routing Diagram
393
Parking / Rear Brake Cable Routing Diagram
393
Repair Instructions
393
Parking / Rear Brake Lever Components
393
Parking / Rear Brake Light Switch Inspection
393
Parking Brake Switch Inspection
393
Ignition / Starter Control Relay (Parking Brake Relay) Inspection
393
Parking / Rear Brake Lever Removal and Installation
394
Parking / Rear Brake Cable Removal and Installation
395
Parking Brake
393
Special Tools and Equipment
395
Recommended Service Material
395
Specifications
395
Tightening Torque Specifications
395
Section 5 Transmission / Transaxle
397
Precautions
399
Precautions for Transmission / Transaxle
399
Automatic Transmission
400
Schematic and Routing Diagram
400
Drive Train Operation (LT-A400
400
Low Gear
401
Diagnostic Information and Procedures
403
Automatic Transmission Symptom Diagnosis
403
Repair Instructions
404
Automatic Transmission Components
404
V-Belt Cooling Duct Removal and Installation
405
(Lt-A400
405
Clutch Engagement and Lock-Up Speed Inspection
406
V-Belt Type Continuously Variable Automatic Transmission Removal and Installation
406
Movable Drive Face Disassembly and Assembly
409
Movable Driven Face Disassembly and Assembly
410
Drive V-Belt Inspection
414
Movable / Fixed Drive Face Parts Inspection
414
Movable / Fixed Driven Face Parts Inspection
415
Clutch Shoe Removal and Installation
415
V-Belt Outer Cover Bearing Removal and Installation
417
V-Belt Inner Cover Disassembly and Assembly
418
Clutch Related Parts Inspection
420
Specifications
421
Service Data (LT-A400
421
Tightening Torque Specifications
422
Special Tools and Equipment
422
Recommended Service Material
422
Special Tool
423
Manual Transmission
424
Diagnostic Information and Procedures
424
Manual Transmission Symptom Diagnosis
424
Repair Instructions
425
Transmission Components (LT-F400
425
Transmission Removal and Installation (LT- F400
426
Transmission Construction
427
Countershaft Gear / Driveshaft Gear
428
Disassembly and Assembly (LT-F400
428
Transmission Reverse Gearshift Cam
429
Disassembly and Assembly (LT-F400
429
Transmission Related Parts Inspection (LT- F400
430
Gear Position (GP) Switch Inspection (LT-F400
430
Gear Position (GP) Switch Removal and Installation (LT-F400
430
Gear Position (GP) Switch Removal and Installation (LT-A400
431
Gearshift Lever Removal and Installation (LT- F400
431
Gearshift Lever Height Inspection and Adjustment (LT-F400
432
Gearshift Shaft / Gearshift Cam Plate Components (LT-F400
433
Gearshift Shaft / Gearshift Cam Plate Removal and Installation (LT-F400
434
Gearshift Linkage Inspection (LT-F400
435
Gearshift Shaft Oil Seal Removal and Installation (LT-A400
436
Specifications
436
Service Data (LT-F400
436
Tightening Torque Specifications
437
Special Tools and Equipment
437
Recommended Service Material
437
Special Tool
437
Precautions
438
Precautions for Clutch System
438
Diagnostic Information and Procedures
438
Clutch System Symptom Diagnosis
438
Clutch
438
Repair Instructions
439
Clutch Components (LT-F400
439
Clutch Removal and Installation (LT-F400
440
Clutch Related Parts Inspection (LT-F400
443
Clutch Cover Disassembly and Assembly
445
Clutch Release Roller Inspection (LT-F400
447
Section 6 Steering
449
Precautions
450
Precautions for Steering
450
Steering General Diagnosis
451
Diagnostic Information and Procedures
451
Steering Symptom Diagnosis
451
Steering / Handlebar
452
Repair Instructions
452
Steering / Handlebars Components
452
Steering Assembly Construction
453
Handlebars Removal and Installation
454
Handlebars Inspection
456
Steering Shaft / Tie-Rod Removal and Installation
456
Steering Parts Inspection
461
Specifications
462
Tightening Torque Specifications
462
Recommended Service Material
463
Special Tool
463
Special Tools and Equipment
463
Section 9 Body and Accessories
465
Component Location
466
Electrical Components Location
466
Precautions
466
Precautions for Electrical System
466
Schematic and Routing Diagram
467
Wiring Diagram
467
Wiring Harness Routing Diagram
474
Wiring Systems
467
Specifications
476
Tightening Torque Specifications
476
Lighting Systems
477
Headlight Construction
477
Front Side Reflector Construction
478
Headlight Components
479
Headlight Bulb Replacement
480
Headlight Beam Adjustment
480
Rear Combination Light Components
481
Rear Combination Light Removal and Installation
481
Rear Combination Light Bulb Replacement
482
Reversing Light Bulb Replacement (for
482
Reversing Light Relay Inspection (for
482
Dimmer Switch Inspection
483
Repair Instructions
477
Specifications
483
Combination Meter / Fuel Meter / Horn
484
Speedometer Components
484
Speedometer Removal and Installation
485
Speedometer Disassembly and Assembly
486
Speedometer Light Bulb / Indicator Light Bulb Replacement
486
Ignition Switch Inspection
486
Ignition Switch Removal and Installation
486
Repair Instructions
484
Specifications
487
Special Tools and Equipment
487
Repair Instructions
488
Exterior Parts
488
Rear Fender Heat Shield Construction
488
Fastener Removal and Installation
489
Exterior Parts Removal and Installation
490
Repair Instructions
494
Body Structure
494
Body Frame Construction
494
Footrest Construction
494
Footrest Removal and Installation
495
Carrier Construction
496
Front Carrier Removal and Installation
497
Rear Carrier Removal and Installation
497
Front Grip Bar Construction
498
Front Grip Bar Removal and Installation
498
Trailer Towing Removal and Instruction
499
Specifications
500
Tightening Torque Specifications
500
Special Tools and Equipment
500
Recommended Service Material
500
Other manuals for Suzuki LT-A400
Setup Manual
33 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Suzuki LT-A400 and is the answer not in the manual?
Ask a question
Suzuki LT-A400 Specifications
General
Brand
Suzuki
Model
LT-A400
Category
Offroad Vehicle
Language
English
Related product manuals
Suzuki LT-A400F
502 pages
Suzuki LT-A450X 2007
139 pages
Suzuki LT-A700X
125 pages
Suzuki LT-A750X/P
711 pages
Suzuki LT-A750XP/Z
136 pages
Suzuki Vinson LT-A500F
350 pages
Suzuki LT-Z50
107 pages
Suzuki LT-F400
140 pages
Suzuki LT-F400F
502 pages
Suzuki 2009 LT-R450
47 pages
Suzuki LT-F500F 2002
382 pages
Suzuki QuadRacer LT-R450
444 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
