Maintenance - Maintenance schedule
4812160001_A.pdf 2014-08-25
Every 2000 hours of operation
Refer to the contents to find the page number of the
sections referred to !
Pos. in fig Action CommentPos. in fig Action Comment
6,10 Change the hydraulic fluid6,10 Change the hydraulic fluid
8 Change the hydraulic fluid filter8 Change the hydraulic fluid filter
12 Change the oil in the drum cartridges12 Change the oil in the drum cartridges
4 Inspect the filter element in the air cleaner Replace as required4 Inspect the filter element in the air cleaner Replace as required
22 Change oil in rear axle differential22 Change oil in rear axle differential
23 Change oil in the rear axle planetary gearing23 Change oil in the rear axle planetary gearing
13 Change the oil in the drum gearbox13 Change the oil in the drum gearbox
32,31 Clean the coolers32,31 Clean the coolers
3 Replace the fuel filter Refer to the engine manual3 Replace the fuel filter Refer to the engine manual
3 Replace the fuel pre-filter Refer to the engine manual3 Replace the fuel pre-filter Refer to the engine manual
2,25 Change the engine oil and oil filter. *) See the engine's
instruction manual
*) 500 h or once every 6
months.
2,25 Change the engine oil and oil filter. *) See the engine's
instruction manual
*) 500 h or once every 6
months.
27,28 Grease the steering bearing / steering chain Optional27,28 Grease the steering bearing / steering chain Optional
7 Check bleeder filter on hydraulic reservoir7 Check bleeder filter on hydraulic reservoir
9 Drain the condensate from hydraulic reservoir9 Drain the condensate from hydraulic reservoir
26 Drain condensate from fuel tank Optional26 Drain condensate from fuel tank Optional
34 Overhaul air conditioning Optional34 Overhaul air conditioning Optional
Check engine's valve clearances Refer to the engine manualCheck engine's valve clearances Refer to the engine manual
19 Check belt tension in the drive belt system Refer to the engine manual19 Check belt tension in the drive belt system Refer to the engine manual
Replace the ventilation filter in the crankcase *) Refer to the engine manual
*) only applies to Stage
IIIB/Tier 4i
Replace the ventilation filter in the crankcase *) Refer to the engine manual
*) only applies to Stage
IIIB/Tier 4i
17 Steering hitch - Tightening17 Steering hitch - Tightening
92
To Next Page
Loading...
Need help?
General
