Daewoo NUBIRA - Page 370

4T40–E AUTOMATIC TRANSAXLE 5A – 5
DAEWOO V–121 BL4
ACCUMULATOR SPRINGS INSTALL 5A–255. . . . . .
CHANNEL PLATE ASSEMBLY
INSTALLATION 5A–255. . . . . . . . . . . . . . . . . . . . . . . .
MANUAL VALVE INSTALL 5A–256. . . . . . . . . . . . . . . .
CHECKBALLS INSTALLATION 5A–256. . . . . . . . . . . .
SPACER PLATE AND GASKETS INSTALL 5A–256.
CONTROL VALVE BODY DISASSEMBLE 5A–258. .
CONTROL VALVE BODY ASSEMBLE 5A–262. . . . .
CONTROL VALVE ASSEMBLY AND
TFP SWITCH INSTALL 5A–266. . . . . . . . . . . . . . . . .
WIRING HARNESS ASSEMBLY
CONNECT 5A–267. . . . . . . . . . . . . . . . . . . . . . . . . . . .
OIL PUMP CLEAN AND INSPECT 5A–268. . . . . . . . .
OIL PUMP ASSEMBLY INSTALLATION 5A–268. . . .
SIDE COVER/GASKETS, DISASSEMBLE,
ASSEMBLE, INSTALL 5A–268. . . . . . . . . . . . . . . . . .
OUTPUT SHAFT SLEEVE ASSEMBLE 5A–270. . . .
OUTPUT SHAFT AND SLEEVE
ASSEMBLY INSTALL 5A–271. . . . . . . . . . . . . . . . . .
SIDE COVER AXLE SEAL INSTALL 5A–270. . . . . . .
STUB SHAFT SLEEVE ASSEMBLE
AND INSTALL 5A–272. . . . . . . . . . . . . . . . . . . . . . . . .
RIGHT HAND AXLE SEAL ASSEMBLE 5A–272. . . .
VEHICLE SPEED SENSOR
INSTALLATION 5A–273. . . . . . . . . . . . . . . . . . . . . . . .
INTER 4TH SERVO DISASSEMBLE,
ASSEMBLE, AND INSTALL 5A–273. . . . . . . . . . . . .
LOW/REVERSE SERVO ASSEMBLY
DISASSEMBLE 5A–275. . . . . . . . . . . . . . . . . . . . . . . .
LOW/REVERSE SERVO ASSEMBLY
ASSEMBLE 5A–275. . . . . . . . . . . . . . . . . . . . . . . . . . .
OIL FEED PIPES ASSEMBLE 5A–275. . . . . . . . . . . .
FILTER ASSEMBLY AND SEAL INSTALL 5A–276. .
OIL LEVEL CONTROL VALVE INSTALL 5A–277. . . .
OIL PAN AND GASKET INSTALL 5A–277. . . . . . . . . .
TORQUE CONVERTER INSTALLATION 5A–278. . .
GENERAL DESCRIPTION AND SYSTEM
OPERATION 5A–279. . . . . . . . . . . . . . . . . . . . . . . . . . . .
TRANSAXLE DEFINITIONS AND
ABBREVIATIONS 5A–279. . . . . . . . . . . . . . . . . . . . . .
TRANSAXLE GENERAL DESCRIPTION 5A–280. . .
TRANSAXLE COMPONENT AND
SYSTEM DESCRIPTION 5A–280. . . . . . . . . . . . . . .
RANGE REFERENCE CHART 5A–283. . . . . . . . . . . .
BTSI AND KEY INTERLOCK SYSTEM 5A–284. . . . .
AUTOMATIC TRANSMISSION VEHICLE
SPEED SENSOR (A/T VSS) 5A–284. . . . . . . . . . . .
AUTOMATIC TRANSMISSION INPUT
(SHAFT) SPEED SENSOR (A/T ISS) 5A–284. . . . .
SHIFT SOLENOIDS: 1–2 AND 2–3 5A–285. . . . . . . .
PRESSURE CONTROL SOLENOID
VALVE (PC SOL. VALVE) 5A–285. . . . . . . . . . . . . . .
TORQUE CONVERTER CLUTCH
SOLENOID VALVE (TCC SOL. VALVE) 5A–286. . .
AUTOMATIC TRANSMISSION FLUID
PRESSURE MANUAL VALVE POSITION
SWITCH (TFP VAL. POSITION SW.) 5A–287. . . . .
TRANSMISSION FLUID
TEMPERATURE (TFT) SENSOR 5A–288. . . . . . . .
TRANSMISSION ELECTRICAL
CONNECTOR 5A–289. . . . . . . . . . . . . . . . . . . . . . . . .
POWERTRAIN CONTROL
MODULE (PCM) 5A–289. . . . . . . . . . . . . . . . . . . . . . .
DATA LINK CONNECTOR (DLC) 5A–290. . . . . . . . . .
PCM INPUTS THAT AFFECT THE
4T40–E TRANSMISSION 5A–290. . . . . . . . . . . . . . .
PARK (ENGINE RUNNING) 5A–291. . . . . . . . . . . . . . .
REVERSE 5A–293. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
NEUTRAL (ENGINE RUNNING) 5A–295. . . . . . . . . . .
OVERDRIVE RANGE – FIRST GEAR 5A–297. . . . . .
OVERDRIVE RANGE – SECOND GEAR 5A–299. . .
OVERDRIVE RANGE – THIRD GEAR 5A–301. . . . .
OVERDRIVE RANGE – FOURTH GEAR 5A–303. . .
OVERDRIVE RANGE – 4–3 DOWNSHIFT 5A–305. .
MANUAL THIRD – THIRD GEAR 5A–307. . . . . . . . . .
MANUAL SECOND – SECOND GEAR 5A–309. . . . .
MANUAL FIRST – FIRST GEAR 5A–311. . . . . . . . . .