KTM 400 EXC EU 2011 User Manual

381lUBRICATION SYSTEM 183
Fllllni UP. with Inllnl all
• Info
- Place a suitable container under the engine.
-
Remove screws •. Remove oil filter cover. with the O-ring.
- Pull the oil filter
insert. out of the oil filter casing.
1 Circlip pliers reverse (51012011000) ( -- p. 255)
- Completely drain the engine oil.
- Thoroughly clean parts and sealing surface.
-
Lay the motorcycle on its side and fill the oil filter housing to about 11, full with
engine oil.
- Fill the oil filter
0 with engine oil and place it in the oil filter container.
- Lubricate the Olring •
of the oil filter cover.
- Refit the
oi I fi Iter cover •.
- Mount and tighten screws •.
Guideline
1 Screw, oil filter cover
110 Nm (7.4 Ibf ft) 1
- Stand the motorcycle upright.
I Too little engine oil or poor-quality engine oil results in premature wear to the engine.
-
Remove the screw cap. on the alternator cover and fill up with engine oil.
Engine oil
(lst
0.35 I (0.37 qt.) Engine oil (SAE lOW/50) ( -- p. 250)
partial quantity
approx.)
- Mount and tighten the screw connection
on the alternator cover.
... Danger
t.,;,J Dangar 01 poisoning Exhaust gases are poisonous and inhaling them may
result in unconsciousness and/or death.
- When running the engine, always make sure there is sufficient ventila-
tion, and
do not start or run the engine in an enclosed space without an
effective exhaust extraction system.
381lUBRICATION SYSTEM 183
Fllllni UP. with Inllnl all
• Info
- Place a suitable container under the engine.
-
Remove screws •. Remove oil filter cover. with the O-ring.
- Pull the oil filter
insert. out of the oil filter casing.
1 Circlip pliers reverse (51012011000) ( -- p. 255)
- Completely drain the engine oil.
- Thoroughly clean parts and sealing surface.
-
Lay the motorcycle on its side and fill the oil filter housing to about 11, full with
engine oil.
- Fill the oil filter
0 with engine oil and place it in the oil filter container.
- Lubricate the Olring •
of the oil filter cover.
- Refit the
oi I fi Iter cover •.
- Mount and tighten screws •.
Guideline
1 Screw, oil filter cover
110 Nm (7.4 Ibf ft) 1
- Stand the motorcycle upright.
I Too little engine oil or poor-quality engine oil results in premature wear to the engine.
-
Remove the screw cap. on the alternator cover and fill up with engine oil.
Engine oil
(lst
0.35 I (0.37 qt.) Engine oil (SAE lOW/50) ( -- p. 250)
partial quantity
approx.)
- Mount and tighten the screw connection
on the alternator cover.
... Danger
t.,;,J Dangar 01 poisoning Exhaust gases are poisonous and inhaling them may
result in unconsciousness and/or death.
- When running the engine, always make sure there is sufficient ventila-
tion, and
do not start or run the engine in an enclosed space without an
effective exhaust extraction system.

KTM 400 EXC EU 2011 Specifications

General

Brand	KTM
Model	400 EXC EU 2011
Category	Motorcycle
Language	English