O2IHANDLEBAR,
INSTRUMENTS
38
Cbeckinllhe
p'lay
in
the
throttle
cable
AdJustlnllhe
p'lay
In
the
throttle
cable
-
Move
the handlebar
to
the straight-ahead position.
Move
the throttle grip back-
wards and forwards
to
ascertain the play in the throttle cable.
1 Play in throttle cable
13
...
5 mm
(0.12
...
0.2
in)
•
If
the throttle cable play does not meet specifications:
- Adjust the play in the throttle cable. (
..
p.
38)
...
Danger
W
Danler
of
poisoninl
Exhaust
gases
are
poisonous and inhaling them may
result in unconsciousness
andlor death.
- When running the engine, always make sure there is sufficient ventila-
tion, and
do
not start or run the engine in
an
enclosed space without
an
effective exhaust extraction system.
- Start the engine and let it run idle.
Move
the handlebar
to
and fro
over
the entire
steeri ng range.
1 The idle speed must not change.
•
If
the idle speed changes:
- Adjust the play in the throttle cable. (
..
p.
38)
-
Remove
the fuel tank. (
..
p.
66)
- Check the throttle cable routing. (
..
p.
37)
-
Move
the handlebar
to
the straight-ahead position.
Push
back sleeves
•.
-
Loosen
nut
•.
Turn adjusting
screw.
in
as
far
as
possible.
-
Loosen
nut e. Turn adjusting
screw.
so
that there
is
play in the throttle cable at
the throttle grip.
Guideline
1 Play in throttle cable
13
...
5 mm
(0.12
...
0.2
in)
- Tighten nut
•.
-
Press
and hold the throttle grip in the closed setting. Turn adjusting
screw.
out
until there
is
no
play in the throttle cable
•.
- Tighten nut
•.
-
Push
sleeves.
on. Check the throttle grip for smooth operation.
- Install the fuel tank. (
..
p.
67)
- Check the play in the throttle cable. (
..
p.
38)
O2IHANDLEBAR,
INSTRUMENTS
38
Cbeckinllhe
p'lay
in
the
throttle
cable
AdJustlnllhe
p'lay
In
the
throttle
cable
-
Move
the handlebar
to
the straight-ahead position.
Move
the throttle grip back-
wards and forwards
to
ascertain the play in the throttle cable.
1 Play in throttle cable
13
...
5 mm
(0.12
...
0.2
in)
•
If
the throttle cable play does not meet specifications:
- Adjust the play in the throttle cable. (
..
p.
38)
...
Danger
W
Danler
of
poisoninl
Exhaust
gases
are
poisonous and inhaling them may
result in unconsciousness
andlor death.
- When running the engine, always make sure there is sufficient ventila-
tion, and
do
not start or run the engine in
an
enclosed space without
an
effective exhaust extraction system.
- Start the engine and let it run idle.
Move
the handlebar
to
and fro
over
the entire
steeri ng range.
1 The idle speed must not change.
•
If
the idle speed changes:
- Adjust the play in the throttle cable. (
..
p.
38)
-
Remove
the fuel tank. (
..
p.
66)
- Check the throttle cable routing. (
..
p.
37)
-
Move
the handlebar
to
the straight-ahead position.
Push
back sleeves
•.
-
Loosen
nut
•.
Turn adjusting
screw.
in
as
far
as
possible.
-
Loosen
nut e. Turn adjusting
screw.
so
that there
is
play in the throttle cable at
the throttle grip.
Guideline
1 Play in throttle cable
13
...
5 mm
(0.12
...
0.2
in)
- Tighten nut
•.
-
Press
and hold the throttle grip in the closed setting. Turn adjusting
screw.
out
until there
is
no
play in the throttle cable
•.
- Tighten nut
•.
-
Push
sleeves.
on. Check the throttle grip for smooth operation.
- Install the fuel tank. (
..
p.
67)
- Check the play in the throttle cable. (
..
p.
38)
To Next Page
Need help?
General
