Scheduled maintenance table
NOTE
HALVE THE SERVICE INTERVALS INDICATED IF THE VEHICLE IS USED IN PARTICULARLY
RAINY OR DUSTY CONDITIONS, ON POOR ROADS OR FOR HIGH PERFORMANCE RIDING.
NOTE
THE TIMES LISTED ON THE SCHEDULED MAINTENANCE TABLE INCLUDE TIME DEDICATED
TO MANAGEMENT ACTIVITIES.
I: CHECK AND CLEAN, ADJUST, LUBRICATE OR REPLACE, IF NECESSARY
C: CLEAN, R: REPLACE, A: ADJUST, L: LUBRICATE
(1) Check and clean and adjust or replace, if necessary, before every journey.
(2) Check and clean, adjust or replace if necessary every 1,000 km (621.37 mi).
(3) Replace at whichever of the following occurs first: 40,000 km (24,854.85 mi) or 4 years.
SCHEDULED MAINTENANCE TABLE
Km x 1,000 (mi x 1,000) 1 (0.6) 10
(6.2)
20
(12.4)
30
(18.6)
40
(24.9)
EVERY
12
MONTH
S
EVERY
24
MONTH
S
Rear shock absorber (bearings - linkage mechanisms) I I I I
Motorcycle set up I I I I I
Spark plug R R
Drive chain (2) I - L I - L I - L I - L I - L I I
Clutch cable L L L L L L L
Front sprocket - rear sprocket - Chain slider I I I I
Steering bearings and steering play I I I I I I I
Wheel bearings - Wheels I I I I I I I
Diagnosis by tool I I I I I I I
Brake discs - Brake pads wear (1) I I I I I I I
Air filter I R I R
Engine oil filter R R R R R R R
Raked I I I I
Vehicle general operation I I I I I I I
Valve clearance A A
Cooling system I I I I
Brake systems I I I I I I I
Safety switches (stand, stop, clutch, extra negative stroke,
gas control)
I I I I I I I
Brake Fluid I I I I I I R
Coolant I I I I I I R
Fork oil (3) R
Engine oil R R R R R R R
Headlight aiming I I I I
Fork oil seals I I
Tyres - pressure / wear (1) I I I I I I I
Nut/bolt tightness I I I I I
Labour time (minutes) 90 110 190 110 280 80 130
NOTE
AT EACH SCHEDULED MAINTENANCE MUST BE VERIFIED WITH THE DIAGNOSTIC TOOL IF
THERE ARE ERRORS AND THE IF THE PARAMETERS ARE CORRECT.
ENSURE THAT THE VEHICLE CALIBRATION IS UP TO DATE AFTER UPDATING THE DIAGNOS-
TIC TOOL.
SCHEDULED MAINTENANCE TABLE RESERVED FOR THE US-LATAM MARKET
I: CHECK AND CLEAN, ADJUST, LUBRICATE OR REPLACE, IF NECESSARY
C: CLEAN, R: REPLACE, A: ADJUST, L: LUBRICATE
RS 660 - Tuono 660 Maintenance
MAIN - 55
To Next Page
Loading...
Need help?
General
