6. COOLING SYSTEM
6-2
XCITING 500
SERVICE INFORMATION
GENERAL INSTRUCTIONS
WARING:
Removing the radiator cap while the engine is hot can allow the coolant to spray out,
seriously scalding you. Always let the engine and radiator cool down before removing the
radiator cap.
CAUTION:
Radiator coolant is toxic. Keep it away from eyes, mouth, skin and clothes.
• If any coolant gets in your eyes, rinse them with water and consult a physician immediately.
• If any coolant in swallowed, induce vomiting, gargle and consult a physician immediately.
• If any coolant gets on your skin or clothes, rinse thoroughly with plenty of water.
NOTE:
Use coolant with silicate inhibitors may cause premature wear of water pump seals or blockage of
radiator passages. Using tap water may cause engine damage.
• This section covers service of the cooling system.
• These services can be done with the engine installed in the frame.
• Add coolant at the reserve tank. Do not remove the radiator cap except to refill or drain the
system.
• All cooling system services can be done with the engine in the frame.
• Avoid spilling coolant on painted surfaces.
• After servicing the system, check for leaks with a cooling system tester.
To Next Page
Loading...
Need help?
General
