Troubleshootins
EM-16
ENGINE MECHANICAL
-
(Diesel ~lectrical System Diagnosis
I2L-T
Others])
Diesel Electrical System Diagnosis
[2L-T
Others]
ENGINE DOES NOT START COLD
HINT:
Battery voltage at least
12
V
-
starter switch OFF.
Engine cranks normally.
Fusible link okay.
Check the voltage marked with an asterisk
(*)
just
as
the starter switch
is
placed at ON because the voltage
will change.
1.
Pre-Heating System (Super Glow Type)
I
Disconnect the water temperature
/
sensor.
1
Yes
t
P
Check for short circuit
and repair if necessary.
Check if indicator light lights up
with starter switch ON.
Light on:
6
-
7
seconds
Check indicator Replace bulb.
No Good
I
I
Bulb OK
-
No
Blown
P
Check fuse.
(See page ST-2)
i
Starter switch OFF
timer connector (on wire harness side).
If okay, pre-heating timer
is
faulty and should be
replaced.
I
after engine
is
started.
I
Fuse
t
If faulty, repair charging system as necessary.
i
If okay, timer
is
faulty and should be replaced.
"Check that there
is
1
V or less to terminal
9.
If okay, timer
is
faulty and should be replaced.
I
"Check for battery voltage to
terminal 1 of pre-heating timer
Starter switch OFF.
-
No
Start engine and check if there
is
voltage at terminal
,
9
of pre-heating timer.
i
"Check if voltage to terminal
1
of
pre-heating timer
is
terminated
I
CONTINUED ON PAGE EM-17
with starter switch ON.
-
No
Pre-Heating Timer
654
3
1
Voltage
To Next Page
Loading...
Need help?
General
