E
INSP
ADJ
CHAPTER 3
PERIODIC INSPECTION AND ADJUSTMENT
MAINTENANCE INTERVAL CHART
.............................................................. 3-1
PERIODIC SERVICE
........................................................................................ 3-2
COWLING ................................................................................................. 3-2
Water separator drain hole............................................................... 3-2
FUEL SYSTEM.......................................................................................... 3-2
Fuel line.............................................................................................. 3-2
Fuel filter replacement ...................................................................... 3-2
CONTROL SYSTEM ................................................................................. 3-2
Throttle link rod adjustment............................................................. 3-2
Idle speed adjustment....................................................................... 3-3
Start-in-gear protection device adjustment .................................... 3-3
POWER UNIT............................................................................................ 3-4
Engine oil level .................................................................................. 3-4
Engine oil replacement ..................................................................... 3-4
Valve clearance adjustment ............................................................. 3-5
POWER TRIM AND TILT (PTT) SYSTEM ................................................ 3-6
PTT fluid check .................................................................................. 3-6
Hydraulic system air bleeding.......................................................... 3-7
LOWER UNIT............................................................................................ 3-7
Gear oil............................................................................................... 3-7
Lower unit leakage check ................................................................. 3-8
GENERAL.................................................................................................. 3-9
Anode ................................................................................................. 3-9
Battery ................................................................................................ 3-9
Spark plugs ...................................................................................... 3-10
Lubrication points ........................................................................... 3-11
To Next Page
Loading...
Need help?
General
