3-1
INSP
ADJ
E
MAINTENANCE INTERVAL CHART
MAINTENANCE INTERVAL CHART
Use the following chart as a guide to general maintenance intervals.
Dependant on operating conditions, adjust the maintenance intervals accordingly.
Item Remarks
Initial Every
Refer to
page
10 hours
(Break-in)
50 hours
(3 months)
100 hours
(6 months)
200 hours
(1 year)
COWLING
Cowling latch Inspect 3-2
FUEL SYSTEM
Fuel line Inspect 3-2
Fuel filter Inspect/replace 3-2
POWER UNIT
Engine oil Inspect/replace 3-4
Oil filter cartridge Replace 3-4
Timing belt Inspect/replace 5-12
Valve clearance Inspect/adjust 3-5
Thermostat Inspect/replace 5-32
Water leakage Inspect —
Motor exterior Inspect —
Exhaust leakage Inspect —
Cooling water passage Inspect/clean —
CONTROL SYSTEM
Throttle cable Inspect/adjust —
Shift cable Inspect/adjust —
Idle speed Inspect/adjust 3-3
Start-in-gear protection
device
Inspect/adjust
3-3
POWER TRIM AND TILT (PTT) SYSTEM
PTT fluid Inspect/change 3-6
LOWER UNIT
Gear oil Change 3-7
Impeller Inspect/replace 6-3
Lower unit leakage Inspect 3-7
Propeller Inspect 6-1
GENERAL
Anode Inspect 3-9
Battery Inspect every month 3-9
Spark plugs Clean/inspect/adjust 3-10
Wires and connectors Adjust/reconnect —
Bolts and nuts Tighten —
Lubrication points Lubricate 3-11
To Next Page
Loading...
Need help?
General
