00.1
Contents Page
00
Tightening torques ......................................................................................................................3
Table of operating fluids ...........................................................................................................9
Key to maintenance intervals ..............................................................................................11
Reading out MoDiTeC fault memory ...............................................................................11
(Inspections I, II, III and IV)
Checking throttle cable play,
adjusting if necessary ..............................................................................................................11
(Inspections I and III)
Changing engine oil, renew oil filter element .............................................................12
(Inspections I, II, III and IV)
Changing oil in gearbox ..........................................................................................................13
(Inspections III and IV)
or at least every 2 years
Changing oil in rear wheel drive; cleaning inductive signal transmitter at
rear wheel .......................................................................................................................................13
(Inspections I, III and IV)
Every 40 000 km (24 000 miles) or at least every
2 years
Renewing fuel filter ...................................................................................................................14
(Inspection III)
In normal operating conditions every 40 000 km (24 000 miles); if fuel quality is poor every
20 000 km (12 000 miles)
Checking battery acid level/topping up if necessary, cleaning/greasing
battery posts .................................................................................................................................16
(Inspections III and IV)
Renewing intake air cleaner
element ............................................................................................................................................16
(Inspection III)
In very dirty and dusty operating conditions, renew every 10 000 km (6 000 miles) or even more fre-
quently if necessary
Renewing Poly-V belt ...............................................................................................................17
(every 60 000 km/36 000 miles)
(Inspection III)
Poly-V belt adjusting procedure:
Checking brake fluid level .........................................................................................................18
Front brake
00 Maintenance and general instructions
To Next Page
Loading...
Need help?
General
