24 SERVICE SCHEDULE 214
24.1 Service schedule
Every 10,000 km (6,214 mi) or every 2 years
Every 5,000 km (3,107 mi) or annually
Once after 1,000 km (621.4 mi)
Check the functioning of the electrical equipment. ○ ● ●
Read out the fault memory using the KTM diagnostics tool. ○ ● ●
Change the engine oil and oil filter, clean the oil screen. ( p. 200) ○ ● ●
Check the front brake linings. ( p. 66) ○ ● ●
Check the rear brake linings. ( p. 70) ○ ● ●
Check the brake discs. ( p. 54) ○ ● ●
Check the brake lines for damage and leakage. ○ ● ●
Check the rear brake fluid level. ( p. 73) ○ ● ●
Check the shock absorber and fork for leaks. ○ ● ●
Check the swingarm bearing. ● ●
Check the wheel bearing for play. ● ●
Check the tire condition. ( p. 53) ○ ● ●
Check the tire air pressure. ( p. 53) ○ ● ●
Check the chain, rear sprocket, and engine sprocket. ( p. 59) ● ●
Check the chain tension. ( p. 58) ○ ● ●
Grease all moving parts (e.g. side stand, hand lever, chain, ...) and check for smooth operation. ○ ● ●
Clean the dust boots of the fork legs. ( p. 15) ● ●
Check the brake fluid level of the front brake. ( p. 68) ○ ● ●
Check the steering head bearing play. ( p. 26) ○ ● ●
Change the spark plugs. ● ●
Check the valve clearance. ○ ●
Check all hoses (e.g. fuel, cooling, bleeder, drainage, etc.) and bellows for cracking, leaks, and correct routing. ○ ●
Check the antifreeze and coolant level. ( p. 195) ○ ● ●
Check the cables for damage and routing without sharp bends. ● ●
Check that the throttle cables are undamaged, routed without sharp bends, and set correctly. ○ ● ●
Change the air filter. Clean the air filter box. ● ●
Check the screws and nuts for tightness. ○ ● ●
Change the front brake fluid. ( p. 69) ●
Change the rear brake fluid. ( p. 74) ●
Check the headlight setting. ( p. 77) ○ ● ●
Check that the radiator fan is functioning properly. ○ ● ●
Final check: Check the vehicle for roadworthiness and take a test ride. ○ ● ●
Read out the fault memory using the KTM diagnostics tool after a test ride. ○ ● ●
Make the service entry in KTM DEALER.NET and in the service record. ○ ● ●
○ One-time interval
● Periodic interval
To Next Page
Loading...
Need help?
General
