Suzuki DF 50 Service Manual

2-1 PERIODIC MAINTENANCE
PERIODIC MAINTENANCE SCHEDULE
The chart below lists the recommended intervals for all the required periodic service work necessary to keep
the motor operating at peak performance and economy.
Maintenance intervals should be judged by number of hours or months, whichever comes first.
NOTE:
More frequent servicing should be performed on outboard motors that are used under severe conditions.
PERIODIC MAINTENANCE CHART
I : Inspect and clean, adjust, lubricate, or replace, if necessary T : Tighten R : Replace
Interval
Item to be serviced
Initial 20 hrs.
or 1 month
Every 50 hrs.
or 3 months
Every 100 hrs.
or 6 months
Every 200 hrs.
or 12 months
Spark plug IR
Breather Hose & Fuel line
IIII
Replace every 2 years
Engine oil RRR
Gear oil RRR
Lubrication III
Anodes & Bonding wires III
Battery III
Fuel mixture check
(O
2
feedback)
Perform every 2 years.
Engine oil filter
Low pressure fuel filter Replace every 400 hours or 2 years.
High pressure fuel filter Replace every 1000 hours.
Ignition timing I
Idle Speed II
Tappet clearance I
Water pump I
Propeller nut & pin III
Bolt & Nuts TTT
RR
Water pump impeller R
I
——
—
—
—
—
—
——
———
—
—
—
—
—
—
—
—
—
—
—
—

Suzuki DF 50 Specifications

General

Engine Type	4-Stroke
Cylinders	3
Displacement	941 cc
Starting System	Electric
Steering	Remote
Engine Type Detail	DOHC 12-Valve
Maximum Output	50 HP
Ignition System	Digital CDI
Alternator	12V 19A
Gear Ratio	2.27:1
Exhaust	Through Prop Hub Exhaust
Trim Method	Power Trim and Tilt
Max Power	50 HP
Alternator Output	12V 19A
Fuel Delivery System	Sequential Multi Point Electronic Fuel Injection
Full Throttle Operating Range	5, 300 - 6, 300 rpm
Engine Oil Capacity	2.7 L
Full Throttle RPM Range	5300 - 6300 RPM
Oil Capacity	2.7 L
Bore x Stroke	72.5 x 76.0 mm (2.85 x 2.99 in.)